Home » Chevrolet Manuals » 2003 Chevrolet S10 Pickup » Manual Viewer

2003 Chevrolet S10 Pickup Owner's Manual - Page 162

2003 Chevrolet S10 Pickup Manual

Get 2003 Chevrolet S10 Pickup PDF manuals and user guides

View all 2003 Chevrolet S10 Pickup manuals

Page 162 highlights

This light should come on, as a check to show you it is working, when the ignition is on and the engine is not running. If the light doesn't come on, have it repaired. This light will also come on during a malfunction in one of two ways: Light Flashing - A misfire condition has been detected. A misfire increases vehicle emissions and may damage the emission control system on your vehicle. Dealer or qualified service center diagnosis and service may be required. 0 If the light stops flashing and remains on steady, see "If the Light I On Steady" following. s If the light continues to flash, when it is safe to do so, stop the vehicle. Find a safe place to park your vehicle. Turn the key off, wait at least 10 seconds and restart the engine. If the light remains on steady, see "If the Light Is On Steady" following. If the light is still flashing, follow the previous steps, and drive the vehicle to your dealer or qualified service center for service. Light On Steady - An emission control system malfunction has been detected on your vehicle. Dealer or qualified service center diagnosis and service may be required. If the Light Is On Steady You may be able to correct the emission system malfunction by considering the following: Did you recently put fuel into your vehicle? If so, reinstall the fuel cap, making sure to fully install the cap. See Filling Your Tank on page 5-7. The diagnostic system can determine if the fuel cap has been left off or improperly installed. A loose or missing fuel cap will allow fuel to evaporate into the atmosphere. A few driving trips with the cap properly installed should turn the light off. Did you just drive through a deep puddle of water? If so, your electrical system may be wet. The condition will usually be corrected when the electrical system dries out. A few driving trips should turn the light off. If the Light Is Flashing The following may prevent more serious damage to your vehicle: 0 Reducing vehicle speed. Avoiding hard accelerations. Avoidingsteep uphill grades. If you are towing a trailer, reduce the amount of cargo being hauled as soon as it is possible. 3-35

Section	Page
Table of Contents	2
Seats and Restraint Systems	8
Front Seats	10
Manual Seats	10
Power Seats	11
Manual Lumbar	11
Power Lumbar	12
Heated Seats	12
Reclining Seatbacks	13
Head Restraints	14
Seatback Latches	15
Rear Seats	16
Rear Seat Operation	16
Jump Seat	17
Safety Belts	18
Safety Belts: They Are for Everyone	18
Questions and Answers About Safety Belts	22
How to Wear Safety Belts Properly	23
Driver Position	24
Safety Belt Use During Pregnancy	30
Right Front Passenger Position	31
Center Passenger Position	31
Rear Seat Passengers (Extended Cab Jump Seat)	33
Rear Seat Passengers (Crew Cab)	34
Safety Belt Extender	37
Child Restraints	38
Older Children	38
Infants and Young Children	40
Child Restraint Systems	44
Where to Put the Restraint (Regular Cab and Extended Cab Pickup)	47
Where to Put the Restraint (Crew Cab Pickup)	48
Top Strap	49
Top Strap Anchor Location	50
Lower Anchorages and Top Tethers for Children (LATCH System)	51
Securing a Child Restraint Designed for the LATCH System	53
Securing a Child Restraint in a Rear Outside Seat Position	53
Securing a Child Restraint in a Center Seat Position	56
Securing a Child Restraint in the Right Front Seat Position	56
Air Bag System	62
Where Are the Air Bags?	64
When Should an Air Bag Inflate?	66
What Makes an Air Bag Inflate?	66
How Does an Air Bag Restrain?	66
What Will You See After an Air Bag Inflates?	67
Air Bag Off Switch	68
Servicing Your Air Bag-Equipped Vehicle	71
Adding Equipment to Your Air Bag-Equipped Vehicle	72
Restraint System Check	73
Checking Your Restraint Systems	73
Replacing Restraint System Parts After a Crash	74
Features and Controls	76
Keys	77
Remote Keyless Entry System	79
Remote Keyless Entry System Operation	80
Doors and Locks	82
Door Locks	82
Power Door Locks	83
Programmable Automatic Door Locks	83
Rear Door Security Locks	85
Lockout Protection	85
Leaving Your Vehicle	86
Third Door	86
Tailgate	87
Windows	88
Manual Windows	88
Power Windows	89
Swing-Out Windows	90
Sliding Rear Window	90
Sun Visors	90
Theft-Deterrent Systems	91
Content Theft-Deterrent	91
Passlock	92
Starting and Operating Your Vehicle	93
New Vehicle Break-In	93
Ignition Positions	93
Starting Your Engine	95
Engine Coolant Heater	97
Automatic Transmission Operation	99
Manual Transmission Operation	102
Four-Wheel Drive	103
Parking Brake	106
Shifting Into Park (P)	107
Shifting Out of Park (P)	109
Parking Your Vehicle	109
Parking Over Things That Burn	110
Engine Exhaust	110
Running Your Engine While You Are Parked	111
Mirrors	112
Manual Rearview Mirror	112
Automatic Dimming Rearview Mirror	112
Outside Manual Mirror	113
Outside Power Mirrors	113
Outside Convex Mirror	114
Outside Heated Mirrors	114
Storage Areas	115
Glove Box	115
Overhead Console	115
Front Storage Area	121
Assist Handles	122
Garment Hooks	122
Luggage Carrier	123
Bed Rails	124
Vehicle Personalization	125
Memory Seat	125
Instrument Panel	128
Instrument Panel Overview	129
Hazard Warning Flashers	131
Other Warning Devices	132
Horn	132
Tilt Wheel	132
Turn Signal/Multifunction Lever	133
Exterior Lamps	139
Interior Lamps	142
Accessory Power Outlets	144
Ashtrays and Cigarette Lighter	145
Climate Controls	146
Climate Control System (Climate Control)	146
Outlet Adjustment	150
Warning Lights, Gages and Indicators	151
Instrument Panel Cluster	152
Speedometer and Odometer	154
Trip Odometer	154
Tachometer	154
Safety Belt Reminder Light	154
Air Bag Readiness Light	155
Air Bag Off Light	156
Charging System Light	157
Voltmeter Gage	158
Up-Shift Light	158
Brake System Warning Light	159
Anti-Lock Brake System Warning Light	160
Engine Coolant Temperature Gage	160
Malfunction Indicator Lamp	161
Oil Pressure Gage	164
Security Light	165
Service Four-Wheel Drive Warning Light	165
Check Gages Warning Light	166
Fuel Gage	166
Low Fuel Warning Light	167
Audio System(s)	168
Setting the Time for Radios without Radio Data Systems (RDS)	168
Setting the Time for Radios with Radio Data Systems (RDS)	169
AM-FM Radio	169
Radio with CD	172
Radio with Cassette and CD	179
Radio with Six-Disc CD	188
Theft-Deterrent Feature (Non-RDS Radios)	198
Theft-Deterrent Feature (RDS Radios)	199
Understanding Radio Reception	199
Care of Your Cassette Tape Player	199
Care of Your CDs	201
Care of Your CD Player	201
Fixed Mast Antenna	201
Driving Your Vehicle	202
Your Driving, the Road, and Your Vehicle	203
Defensive Driving	203
Drunken Driving	203
Control of a Vehicle	206
Braking	207
Locking Rear Axle	209
Steering	210
Off-Road Recovery	212
Passing	212
Loss of Control	214
Off-Road Driving with Your Four-Wheel-Drive Vehicle	215
Driving at Night	228
Driving in Rain and on Wet Roads	230
City Driving	233
Freeway Driving	234
Before Leaving on a Long Trip	235
Highway Hypnosis	236
Hill and Mountain Roads	237
Winter Driving	239
If You Are Stuck: In Sand, Mud, Ice or Snow	243
Towing	246
Towing Your Vehicle	246
Recreational Vehicle Towing	246
Loading Your Vehicle	250
Truck-Camper Loading Information	253
Trailer Recommendations	255
Pickup Conversion to Chassis Cab	255
Towing a Trailer	255
Service and Appearance Care	264
Service	266
Doing Your Own Service Work	266
Adding Equipment to the Outside of Your Vehicle	267
Fuel	268
Gasoline Octane	268
Gasoline Specifications	268
California Fuel	269
Additives	269
Fuels in Foreign Countries	269
Filling Your Tank	270
Filling a Portable Fuel Container	272
Checking Things Under the Hood	273
Hood Release	273
Engine Compartment Overview	275
Engine Oil	278
Engine Air Cleaner/Filter	283
Automatic Transmission Fluid	284
Manual Transmission Fluid	288
Hydraulic Clutch	289
Engine Coolant	290
Radiator Pressure Cap	293
Engine Overheating	293
Cooling System	296
Engine Fan Noise	303
Power Steering Fluid	304
Windshield Washer Fluid	305
Brakes	306
Battery	309
Jump Starting	310
Rear Axle	315
Four-Wheel Drive	316
Front Axle	317
Bulb Replacement	318
Halogen Bulbs	318
Headlamps	318
One-Piece Front Turn Signal Lamps	320
Two-Piece Front Turn Signal Lamps	321
Center High-Mounted Stoplamp (CHMSL)	322
Taillamps	323
Replacement Bulbs	323
Windshield Wiper Blade Replacement	324
Tires	327
Inflation -- Tire Pressure	328
Tire Inspection and Rotation	329
When It Is Time for New Tires	330
Buying New Tires	331
Uniform Tire Quality Grading	332
Wheel Alignment and Tire Balance	333
Wheel Replacement	333
Tire Chains	335
If a Tire Goes Flat	335
Changing a Flat Tire	336
Compact Spare Tire	348
Appearance Care	349
Cleaning the Inside of Your Vehicle	349
Care of Safety Belts	352
Weatherstrips	352
Cleaning the Outside of Your Vehicle	352
Sheet Metal Damage	354
Finish Damage	354
Underbody Maintenance	355
Chemical Paint Spotting	355
GM Vehicle Care/Appearance Materials	355
Vehicle Identification	357
Vehicle Identification Number (VIN)	357
Service Parts Identification Label	357
Electrical System	358
Add-on Electrical Equipment	358
Headlamps	358
Windshield Wiper Fuses	358
Power Windows and Other Power Options	358
Fuses and Circuit Breakers	358
Capacities and Specifications	364
Capacities and Specifications	365
Normal Maintenance Replacement Parts	366
Maintenance Schedule	368
Maintenance Schedule	369
Introduction	369
Your Vehicle and the Environment	369
Maintenance Requirements	369
How This Section is Organized	370
Part A: Scheduled Maintenance Services	371
Using Your Maintenance Schedule	371
Selecting the Right Schedule	372
Short Trip/City Scheduled Maintenance	374
Long Trip/Highway Scheduled Maintenance	384
Part B: Owner Checks and Services	392
At Each Fuel Fill	392
At Least Once a Month	392
At Least Twice a Year	393
At Least Four Times a Year	394
At Least Once a Year	394
Part C: Periodic Maintenance Inspections	397
Steering, Suspension and Front Drive Axle Boot and Seal Inspection	397
Exhaust System Inspection	397
Fuel System Inspection	397
Engine Cooling System Inspection	398
Throttle System Inspection	398
Transfer Case and Front Axle (Four-Wheel Drive) Inspection	398
Brake System Inspection	398
Part D: Recommended Fluids and Lubricants	399
Part E: Maintenance Record	401
Customer Assistance Information	404
Customer Assistance Information	405
Customer Satisfaction Procedure	405
Online Owner Center	407
Customer Assistance for Text Telephone (TTY) Users	407
Customer Assistance Offices	407
GM Mobility Program for Persons with Disabilities	408
Roadside Assistance Program	409
Courtesy Transportation	411
Reporting Safety Defects to the United States Government	413
Reporting Safety Defects to the Canadian Government	414
Reporting Safety Defects to General Motors	414
Service Publications Ordering Information	414

Match case Limit results 1 per page

This light should come

on, as a

check to show

you

working,

when

the ignition is on

and the engine is

not

running.

the light doesn’t

come on, have it

repaired. This light will also come

on during a

malfunction in one

two

ways:

Light

Flashing

A misfire condition has been

detected.

A misfire increases vehicle emissions

and

may

damage

the emission control system

your

vehicle.

Dealer

or qualified service center

diagnosis

and service may

be required.

Light On Steady

An emission control system

malfunction has

been detected on

your vehicle.

Dealer

or qualified service center diagnosis

and service may

be required.

the

Light Is Flashing

The following may prevent more serious damage to

your

vehicle:

Reducing vehicle speed.

Avoiding hard accelerations.

Avoiding steep uphill grades.

If you

are towing a trailer, reduce the amount of

cargo being hauled

soon as it is possible.

the light stops flashing and remains on steady, see

“If

the Light

On Steady” following.

the light continues to flash, when it is

safe

to do

so,

stop

the

vehicle.

Find a safe place to park your vehicle.

Turn the key

off,

wait

at least

seconds and restart

the engine. If the light remains on steady, see

“If

the Light

On Steady” following.

the light is still

flashing, follow the previous steps, and drive the vehicle

to your dealer or qualified service center for service.

If the Light

Steady

You

may

be able to correct the emission system

malfunction by considering the following:

Did you recently put fuel into your vehicle?

so,

reinstall the fuel cap,

making sure to fully install

the cap.

See

Filling

Your

Tank

on page

5-7.

The

diagnostic system

can determine

the fuel cap

has

been left

off

or improperly installed. A loose or missing

fuel cap will allow fuel to evaporate into

the atmosphere.

few driving trips with the cap properly installed

should turn the light

off.

Did you just drive through a

deep puddle of water?

so,

your electrical system

may

wet. The condition

will usually be corrected when the electrical system

dries out. A

few driving trips should turn the light

off.

3-35