Samsung MW1150WA Service Manual

Samsung MW1150WA Manual

Get Samsung MW1150WA PDF manuals and user guides View all Samsung MW1150WA manuals
Add to My Manuals
Save this manual to your list of manuals

Samsung MW1150WA manual content summary:

  • Samsung MW1150WA | Service Manual - Page 1
    MICROWAVE OVEN MW1150WA SERVICE Manual MICROWAVE OVEN CONTENTS 1. Precaution 2. Specifications 3. Operating Instructions 4. Disassembly and Reassembly 5. Alignment and Adjustments 6. Trouble 7. Exploded Views and Parts List 8. PCB Diagrams 9. Schematic Diagrams SEA
  • Samsung MW1150WA | Service Manual - Page 2
    of hinges and latches, (5) evidence of dropping or abuse. (c) Before turning on microwave power for any service test or inspection within the microwave generating compartments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity, and connections. (d) Any
  • Samsung MW1150WA | Service Manual - Page 3
    the procedures described in this manual. This product complies with Federal Performance Standard 21 CFR Subchapter J (DHHS). 2. Microwave emission check should be performed to prior to servicing if the oven is operative. 3. If the oven operates with the door open : Instruct the user not to operate
  • Samsung MW1150WA | Service Manual - Page 4
    Servicing Precautions especially for flame resistance and dielectric strength specifications. A replacement part that does not have the same safety characteristics as the fire or other hazards. NOTE : Connect the oven to a 20A. When connecting the oven to a 15A, make sure that circuit breaker can
  • Samsung MW1150WA | Service Manual - Page 5
    of Specifications TIMER POWER SOURCE POWER CONSUMPTION OUTPUT POWER OPERATING FREQUENCY MAGNETRON COOLING METHOD OUTSIDE DIMENSIONS NET WEIGHT SHIPPING WEIGHT 99 MINUTES 99SECONDS 120V 60Hz, AC MICROWAVE : 1,550W FROM 110W 1100W ( 10 LEVEL POWER ) 2,450MHz OM75PH(31)ESS COOLING FAN MOTOR 2019
  • Samsung MW1150WA | Service Manual - Page 6
    3. Operating Instructions 3-1 Control Panel 3-2 Features & External Views Door Ventilation Holes Light Safety Interlock Holes Door Latches Glass Tray Guide Roller Control Panel Open Door PushButton 297mm 377mm 523mm 249mm 413mm
  • Samsung MW1150WA | Service Manual - Page 7
    . 4. Remove screws securing the magnetron to the wave guide. 5. Take out the magnetron very carefully. 6. Remove 7. Take out the fan motor assembly. 8. Remove the oven lamp by rotating to pull out from hole of air sure that its antenna does not hit any adjacent parts, or it may be damaged. NOTE2: When
  • Samsung MW1150WA | Service Manual - Page 8
    Removal of Door "E" Following the procedure as shown in the figure, insert and bend a thin metal plate between Door "E" and Door "A" until you hear the 'tick' sound. 1. Insertion depth of the thin metal plate should be 0.1mm or less. 4-3-3 Removal of Key Door & Spring Remove pin hinge from Door
  • Samsung MW1150WA | Service Manual - Page 9
    three switches operate properly, check if any other part such as the control circuit board, blower motor or high voltage transformer is defective. 4-5 Replacement of Drive Motor 1. Take out the glass tray, guide roller from cavity. 2. Turn the oven upside down to replace the drive motor. 3. Remove
  • Samsung MW1150WA | Service Manual - Page 10
    is recommended for smoother removal. 3. When installing new membrane key board, make sure that the surface of escutcheon base is cleaned sufficiently so that any problems (shorted contacts or uneven surface) can be avoided. Membrane panel
  • Samsung MW1150WA | Service Manual - Page 11
    advisable to attempt measurement of the high voltage. 3. Before touching any oven components or wiring, always unplug the oven from its power source and discharge the high voltage capacitor. 5-1 High Output17V) Resistance SLV-4290U 379 10.23 31.91 Magnetron Antenna Gasket Plate Cooling Fins
  • Samsung MW1150WA | Service Manual - Page 12
    them from the main circuit by disconnecting the leads. 2. Operate the microwave oven with a water load in the oven. Set the power level set to high. 3. Check continuity between hazard, replace parts in accordance with the wiring diagram and be sure to use the correct part number for the following
  • Samsung MW1150WA | Service Manual - Page 13
    NOT ALLOW EXPOSURE TO MICROWAVE RADIATION FROM MICROWAVE GENERATOR OR OTHER PARTS CONDUCTING MICROWAVE ENERGY. The output power of the magnetron can be measured by performing a water temperature rise test. Equipment needed : * Two 1-liter cylindrical borosilicate glass vessel (Outside diameter 190
  • Samsung MW1150WA | Service Manual - Page 14
    more than 4 mW/cm 2 after determining that all parts are in good condition, functioning properly and the identical parts are replaced as listed in this manual notift that fact to ; CENTRAL SERVICE CENTER 5-13-2 At least once a year have the microwave energy survey meter checked for accuracy by its
  • Samsung MW1150WA | Service Manual - Page 15
    6. Troubleshooting PRECAUTION 1. CHECK GROUNDING BEFORE CHECKING FOR TROUBLE. 2. BE CAREFUL OF THE HIGH VOLTAGE CIRCUIT. 3. DISCHARGE THE HIGH VOLTAGE CAPACITOR. 4. WHEN CHECKING THE CONTINUITY OF THE SWITCHES OR TRANSFORMER, DISCONNECT ONE LEAD WIRE FROM THESE PARTS AND THEN CHECK CONTINUITY
  • Samsung MW1150WA | Service Manual - Page 16
    Check wire of door sensing switch. Oven does not operate and return to microwave due to its characteristics. Wrap thinner parts of the food with aluminum foil. Use plastic wrap or cover with a lid. Stir once or twice while cooking foods such as soup, cocoa, or milk. Noise from the turntable
  • Samsung MW1150WA | Service Manual - Page 17
    7. Exploded Views and Parts List 7-1 Exploded Views MD11 MD04 MD05 MD03 MD02 MD06 MD07 MD10 MM01 MM171 MM55 MM34 MM07 MM06 MM03 MD01 MM10 MM17 MC06 MC03 MC02 MC05
  • Samsung MW1150WA | Service Manual - Page 18
    2N,80/70,125V15A/250V7.5A,1 MM171 DE47-20194C THERMOSTAT -,PW2N,-,-,75C,65C,-,30.0,-,-,187 HORIZATAL MM18 DE74-20015G TRAY-COOKING -,T6,PI318,1115G,MW5896W,- MM19 DE97-00222A ASSY-GUIDE ROLLER NC-1.2CUFT,SPS(C832) BROWN,D16.0,- MM20 DE67-00106A COUPLER PPS,-,8g,BRN,MW1250WA,NC-1.2 MM22 DE31
  • Samsung MW1150WA | Service Manual - Page 19
    Parts List No. MC01 MC02 MC03 MC04 MC05 MC06 MC07 MC13 MD01 MD02 MD03 MD04 MD05 MD06 MD07 MD10 MD11 Code No. Description Specification - ASSY CONTROL-BOX -,MW1150WA(NC-12),WHT,M-DESIGN DE34-00105E SWITCH MEMBRANE MW1150WA 1 1 1 1 1 1 1 1 S.N.A 1 1 1 1 1 1 1 1 S.N.A : SERVICE NOT AVAILBLE
  • Samsung MW1150WA | Service Manual - Page 20
    7-4 Standard Parts List Code No. DE60-10080B DE60-10080B DE60-10082H DE60-10082H DE60-10082H DE60-10082H DE60-10082H DE60-10082H DE60-10082H DE60-10082H DE60-10082H
  • Samsung MW1150WA | Service Manual - Page 21
    8. P.C.B Diagrams 8-1 P.C.B Diagrams
  • Samsung MW1150WA | Service Manual - Page 22
    8-2 P.C.B Parts List Code No. 3501-001155 3501-001188 3708-001510 DE07-00021K DE09-00054A DE26-00037A DE30-20016A DE92-00695A 0401-001083 0402-001103 0403-001288
  • Samsung MW1150WA | Service Manual - Page 23
    USE 16 GA 105° C THERMOPLASTIC COVERED WIRE EXCEPT FOR HIGH VOLTAGE LEADS OR AS NOTED ON SPECIAL LEADS. WARNING POWER MUST BE DISCONNECTED BEFORE SERVICING THIS APPLIANCE SECONDARY SWITCH TOP ORG RED ORG BLK BLU BLK BLK BLU BLU WHT DOOR SENSING SWITCH BOTTOM MONITOR SWITCH CENTER BLK WHT
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
SERVICE
MICROWAVE OVEN
CONTENTS
MICROWAVE OVEN
1. Precaution
2. Specifications
3. Operating Instructions
4. Disassembly and Reassembly
5. Alignment and Adjustments
6. Trouble
7. Exploded Views and Parts List
8. PCB Diagrams
9. Schematic Diagrams
Manual
MW1150WA
SEA