Weber 900 LP Owner Manual

Weber 900 LP Manual

Get Weber 900 LP PDF manuals and user guides View all Weber 900 LP manuals
Add to My Manuals
Save this manual to your list of manuals

Weber 900 LP manual content summary:

  • Weber 900 LP | Owner Manual - Page 1
    900 LP Gas Barbecue Owner's Manual Serial Number Please use this number in registering your warranty and any correspondence with the factory. WEBER WEBER ® NationalPROPANEGAS Association WARNING: Follow all leak check procedures carefully in this manual prior to barbecue operation. Do this even
  • Weber 900 LP | Owner Manual - Page 2
    . See instructions in this manual for correct procedures. ƽ Do not operate the Weber Gas Barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber Gas Barbecue. ƽ Do
  • Weber 900 LP | Owner Manual - Page 3
    to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 10 years, Flavorizer Bars, 3 years, Cast Iron Cooking Grates, 5 years, All Remaining Parts, 5 years, when assembled and operated
  • Weber 900 LP | Owner Manual - Page 4
    AND TRADEMARKS © 1997 Weber. Weber, , Flavorizer and Crossover are registered U.S. trademarks; Spirit, Gas Catcher, FlameCheck, and Spider Stopper are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Weber Gas Barbecues are covered under the
  • Weber 900 LP | Owner Manual - Page 5
    flavoring, letting excess fat drip past to help prevent flare-ups. e) Separate burners for temperature control. f) Crossover Ignition System with Gas Catcher Ignition Chamber. g) Fuel scale indicates LP gas supply. h) Catch pan catches excess grease. IMPORTANT NEW FEATURES: Your Weber Gas Barbecue
  • Weber 900 LP | Owner Manual - Page 6
    General Instructions Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in
  • Weber 900 LP | Owner Manual - Page 7
    may occur. If a part is missing, do not go back to the store. Call the Weber Customer Service Center toll free 1-800-446-1071 to receive immediate assistance. Have your owner's manual and serial number of the barbecue available for reference. LP tank Bottom tray Cooking grates (2) LP tank filler
  • Weber 900 LP | Owner Manual - Page 8
    Left frame Right frame Wheel frame Leg frame Frame connector Work table Swing table assembly Support rod Accessory racks (2) Warming rack Flavorizer Bars (5) Tank panel assembly Front panel Catch pan holder Catch pan Drip pans (2) Manifold bracket Thermometer ER Wheels (2) Fuel scale assembly 8 WE
  • Weber 900 LP | Owner Manual - Page 9
    Check contents of hardware packs Burner control knobs (3) Tool holders (3) Tubing plugs (7) (two are spares) Support rod holder Swing table end bracket Hinge pins (2) (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size) 1/4-20 x 2 inch bolt (actual size) 1/4-20 x 1 3/4 inch bolts (2) (actual
  • Weber 900 LP | Owner Manual - Page 10
    and a block of wood. Set one end of wheel frame on the block of wood (or other hard, protected surface). Put one wheel on axle, WEBER side facing up, and tap on one hubcap. Figure 1. Repeat with other wheel and hubcap. ER WE B ER WE B Step 3 Assemble top frame You will
  • Weber 900 LP | Owner Manual - Page 11
    holes in the frame and insert the plastic buttons through the front panel and frame. Figure 5. Plastic buttons Fuel scale decal View from rear of barbecue Figure 3 Step 5 Install tubing plugs You will need: two tubing plugs and a hammer. Insert tubing plugs into the ends of the leg frame. Figure
  • Weber 900 LP | Owner Manual - Page 12
    the frame brace. Figure 6. Burner tubes Frame brace Your Weber Gas Barbecue burner assembly has been factory assembled, pressure and flame tested. you answered NO, the burners are misaligned. Contact Weber-Stephen Customer Service. Do not use barbecue. Guide screw Figure 6 Slide the cooking box to
  • Weber 900 LP | Owner Manual - Page 13
    brace Frame brace Figure 9 Tank panel tabs Figure 10 Slide tank panel up until notch at bottom of panel fits over the cross brace. Insert one bolt with washer through the hole in the bottom of the tank panel, through the wheel frame and into the end of the frame connector. Insert
  • Weber 900 LP | Owner Manual - Page 14
    12. Step 11 Install igniter Note - The igniter wires are already attached to the Gas Catcher Ignition Chamber and the igniter. This was done to factory test the ignition Insert the top of the igniter up through the large part of the keyhole in the frame brace. Figure 13 (b). Loosen the igniter lock
  • Weber 900 LP | Owner Manual - Page 15
    resolved the issue to your satisfaction, then call Weber-Stephen Products Co., Customer Service Center. To fill, take the LP tank and filler adapter to an RV center or look gas-propane in the phone book for other sources of LP gas. ƽWARNING: We recommend that your LP tank be filled at an authorized
  • Weber 900 LP | Owner Manual - Page 16
    . Close by turning clockwise. Hook the LP tank onto the fuel scale. Loosen the tank lock wing nut. Swing the tank lock down. Tighten the wing nut. Figure 16. E Tank lock wing nut F Figure 16 (a) Male fitting Collar Hose Regulator (b) Tank valve Valve handwheel close clockwise Pressure
  • Weber 900 LP | Owner Manual - Page 17
    water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. c) Valves to manifold connections. Figure 19 (c). d) The hose to regulator connection. Figure 19 (d). ƽWARNING: If there is a leak at connections
  • Weber 900 LP | Owner Manual - Page 18
    and Cooking Grates You will need: five Flavorizer Bars and two cooking grates. Set the Flavorizer Bars side to side in the cooking box. Figure 20. Step 18 Install the bottom tray You will need: bottom tray, catch pan holder, catch pan and one drip pan. Figure 20 Set the cooking grates onto the
  • Weber 900 LP | Owner Manual - Page 19
    You will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of the barbecue. Insert hinge pins from the outside. Insert hair pin cotters into the small holes in the hinge pins. Figure 25. Hair pin cotter Hinge pin
  • Weber 900 LP | Owner Manual - Page 20
    , support rod, support rod holder and swing table end bracket. Allow the slide bar to hang down. Push the support rod into the lower support bracket our Customer Service Center to order a new part. Install support rod holder on leg. Figure 28 (d). Hook the support rod into the support rod holder.
  • Weber 900 LP | Owner Manual - Page 21
    , two accessory racks, warming rack, three tubing plugs and thermometer. Set the accessory rack across the bottom braces in front of the frame connector. Figure 29 (a). Set the second accessory rack across the bottom braces in the back of the frame connector. Figure 29 (b). Open the lid and set the
  • Weber 900 LP | Owner Manual - Page 22
    not use the barbecue. Replace using only Weber authorized replacement manifold assembly. Order from WeberStephen Products Co., Customer Service Center or authorized LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP
  • Weber 900 LP | Owner Manual - Page 23
    Manual Lighting ƽ DANGER Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not the LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank valve
  • Weber 900 LP | Owner Manual - Page 24
    : Turn your Weber Gas Barbecue OFF and wait for it to cool before cleaning. ƽCAUTION: Do not clean your Flavorizer Bars or cooking grates in a self-cleaning oven. Replacement cooking grates and Flavorizer Bars are available through your retailer or the Weber-Stephen Products Service Center. Outside
  • Weber 900 LP | Owner Manual - Page 25
    Cooking Grates ƽWARNING: Follow all safety instructions provided with your barbecue. Do not drop cast iron grates, or a vegetable cooking spray and heat in grill or oven as indicated above. Maintenance - Clean grates by turning on the barbecue burner control knobs to HHH and wipe off debris
  • Weber 900 LP | Owner Manual - Page 26
    tanks are not compatible with your barbecue connection. Scale setting wing nut Tank lock wing nut Connecting the filled LP tank ƽWARNING: Make sure that the LP tank valve is closed. Close by turning clockwise. ƽ DANGER Do not use an open flame to check for gas leaks. Be sure there are no sparks or
  • Weber 900 LP | Owner Manual - Page 27
    . Figure 5 (a). Push the male fitting of the regulator into the quick disconnect, and maintain pressure. Slide the collar gas and contact Weber-Stephen Customer Service. Do not use the barbecue. g) When leak checks are complete, turn gas supply OFF and rinse connections with water. LP Tank The LP
  • Weber 900 LP | Owner Manual - Page 28
    , bugs etc. Liquid Propane (LP) Tank(s) s The LP tank and connections supplied with your Weber Gas Barbecue have been designed and tested to meet government, American Gas Association and Underwriters Laboratories requirements. s Replacement LP tanks supplied by Weber satisfy the requirements. Check
  • Weber 900 LP | Owner Manual - Page 29
    connections. Figure 8 (c). d) The hose to regulator connection. Figure 8 (d). ƽWARNING: If there is a leak at connections (b), (c) or (d), turn OFF the gas. DO NOT OPERATE THE BARBECUE. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at the source and rinse
  • Weber 900 LP | Owner Manual - Page 30
    all the burner ports are fully open. Figure 13 ƽCAUTION: Do not enlarge the burner ports when cleaning. Replacing Main Burners a) Your Weber Gas Barbecue must be OFF and cool. b) Turn gas OFF at source. c) Remove control panel: take off the burner control knobs. Remove the screws holding the control
  • Weber 900 LP | Owner Manual - Page 31
    burner assembly out from under the guide screw and washer in the corners of the cooking box. Figure 16. Guide screw (b) Figure 18 i) Reinstall Stopper Guards do not fit tightly, contact Weber-Stephen Customer Service. ƽWARNING: After reinstalling the gas lines, they should be leak checked with
  • Weber 900 LP | Owner Manual - Page 32
    is loose in the frame. Tighten if necessary; see Step "Install igniter" for correct procedure. If the Crossover Ignition System still fails to light, contact Weber-Stephen Customer Service.
  • Weber 900 LP | Owner Manual - Page 33
    you preheating barbecue in the All burners on high for 10 to 15 prescribed manner? minutes for preheating. Are the cooking grates and Flavorizer Bars heavily coated with burned-on grease? Clean thoroughly. (See Section "Periodic Cleaning".) ṇCAUTION: Do not line the bottom tray with aluminum
  • Weber 900 LP | Owner Manual - Page 34
    1 2 3 4 5 6 7 8 9 10 11-12 13 14 15 16 17 18 19 20 ® ® E BE R W E BE R W 21 22 23 24 27 21 2526 28 34 29 30 31 11 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 65 51-53 50 54 55 56-57 58 59
  • Weber 900 LP | Owner Manual - Page 35
    . Have your owner's manual and serial number of the barbecue available for reference. Weber-Stephen Products Company Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (800) 446-1071 1 Lid (assembly) 2 Lid handle 3 Warming rack 4 Flavorizer bars (5) 5 Cooking grates (2) 6 Work
  • Weber 900 LP | Owner Manual - Page 36
    a Weber Barbecue. Our family here at Weber has worked hard to produce the highest quality products for your satisfaction. While we give much attention to our products, an occasional error may occur. Our knowledgeable Customer Service staff is prepared to help you with any problems with parts or
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
W
E
B
E
R
W
E
B
E
R
900 LP
Gas Barbecue
Serial Number
Please use this number in registering your warranty and
any correspondence with the factory.
Owner’s Manual
WARNING: Do not try to light this appliance
without reading "Lighting" instructions
section of this manual.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
FOR YOUR SAFETY
If you smell gas:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, immediately call your
gas supplier or your fire department.
FOR YOUR SAFETY
1.
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2.
An LP tank not connected for use shall
not be stored in the vicinity of this or
any other appliance.
WARNING: Follow all leak check procedures
carefully in this manual prior to barbecue
operation. Do this even if barbecue was
dealer assembled.
National
Association
PROPANE
GAS
®
98650
11/97