Weslo 750 Instruction Manual - Page 3

TROUBLESHOOTING AND MAINTENANCE TIGHTENING THE CABLES Woven cable, the type of cable used on the weight system, can stretch slightly when it is first used. If there is slack in the cables before resistance is felt, the cables should be tightened. Slack can be removed by moving a 90mm Pulley (34), the Cable Trap (36), and two Finger Guards (35) to a set of holes closer to the centre of the two Pulley Plates (44). Remove the M10 Nylon Locknut (68) and the M10 x 52mm Bolt (52) and re-attach the Pulley, Cable Trap, and Finger Guards to the new set of holes in the Pulley Plates with the Bolt and Locknut. Slack can also be removed by moving the 90mm Pulley (34), the Cable Trap (36), and two Finger Guards (35) to the higher set of holes in the "U"-bracket (43). Remove the M10 Nylon Locknut (68) and the M10 x 52mm Bolt (52) and re-attach the Pulley, the Cable Trap, and two Finger Guards to the higher set of holes in the "U"-bracket with the Bolt and Locknut. Slack can also be removed from the cables by tightening the M8 Washer (71) and M8 Nylon Locknut (69) attaching the Short Cable (47) to the "U"-bracket (43). The High Cable (not shown) and the Small "U"-bracket (not shown) can be adjusted in the same manner. Make sure that the cables are not too tight or the Top Weight (not shown) will be lifted off the weight stack. 52 35 36 44 35 68 34 47 43 71 52 69 68 35 36 34 35 18 IMPORTANT PRECAUTIONS WARNING: To reduce the risk of serious injury, read the following important precau- tions before using the weight system. 1. Read all instructions in this manual and in the accompanying literature and all warnings on the weight system before using the weight system. Use the weight system only as described in this manual. 6. Inspect and properly tighten all parts regularly. Replace any worn parts immediately. 7. Keep children under the age of 12 and pets away from the weight system at all times. 2. It is the responsibility of the owner to ensure that all users of the weight system are adequately informed of all precautions. 8. Always wear athletic shoes for foot protection when using the weight system. 9. Keep hands and feet away from moving parts. 3. The weight system is intended for home use only. Do not use the weight system in a commercial, rental, or institutional setting. 4. Keep the weight system indoors, away from moisture and dust. Place the weight system on a level surface, with a mat beneath it to protect the floor or carpet. Make sure that there is enough clearance around the weight system to mount, dismount, and use the weight system. 5. This weight system has an open weight stack; the weight stack must not be accessible from any point outside of the user's field of view. To prevent access to the weight stack, place the weight system in a corner or bay of a room, as shown in the drawing below. There must be no more than 1 meter (3 ft. 4 in.) of clearance between the weight system and the adjacent walls. Wall 10. The weight system is designed to support a maximum user weight of 135 kg (300 lbs). 11. Always stand on the foot plate when performing an exercise that could cause the weight system to tip. 12. Never release the arms, leg lever, or lat bar whilst weights are raised; the weights will fall with great force. 13. Always disconnect the lat bar from the weight system when performing an exercise that does not use the lat bar. 14. The weight system is designed to be used only with the included weight. Do not use the weight system with dumbbells or any other type of weight to increase the resistance. 15. Make sure that the cables remain on the pulleys at all times. If the cables bind whilst you are exercising, stop immediately and make sure that the cables are on all of the pulleys. 16. If you feel pain or dizziness at any time whilst exercising, stop immediately and begin cooling down. WARNING: Before beginning this or any exercise program, consult your physician. This is especially important for persons over the age of 35 or persons with pre-existing health problems. Read all instructions before using. ICON assumes no responsibility for personal injury or property damage sustained by or through the use of this product. 3