Poulan PP16H44A User Manual - Page 25

STORAGE diately prepare your tractor for storage at the end of ason or if the unit will not be used for 30 days or more. CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. kCT0R we mower from tractor for winter storage. When ,r is to be stored for a period of time, clean it thor', remove all dirt, grease, leaves, etc. Store in a dry area. lean entire tractor (See "CLEANING" in the Customer esponsibilities section of this manual). aspect and replace belts, if necessary (See belt relacement instructions in the Service and Adjustments action of this manual). ubricate as shown in the Customer Responsibilities action of this manual. e sure that all nuts, bolts and screws are securely stened. Inspect moving parts for damage, breakage id wear. Replace if necessary. ouch up all rusted or chipped paint surfaces; sand )htly before painting. TERY ully charge the battery for storage: fter a period of time in storage, battery may require charging. o help prevent corrosion and power leakage during rig periods of storage, battery cables should be isconnected and battery cleaned thoroughly (see "TO LEAN BATTERY AND TERMINALS" in the Cus)rner Responsibilities section of this manual). fter cleaning, leave cables disconnected and place ables where they cannot come in contact with battery e sure battery drain tube is securely attached. ENGINE FUEL SYSTEM IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, OR TANK DURING STORAGE. ALSO. EXPERIENCE INDICATES THAT ALCOHOL BLENDED FUELS (CALLED GASOHOL OR USING ETHANOL OR METHANOL) CAN ATTRACT MOISTURE WHICH LEADS TO SEPARATION AND FORMATION OF ACIDS DURING STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL SYSTEM OF AN ENGINE WHILE IN STORAGE. • Drain the fuel tank. • Start the engine and let it run until the fuel lines and carburetor are empty. • Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur. • Use fresh fuel next season. NOTE: Fuel stabilizer is an acceptable alternative in minimizing the formation of fuel gum deposits during storage. Add stabilizer to gasoline in fuel tank or storage container. Always follow the mix ratio found on stabilizer container. Run engine at least 10 minutes after adding stabilizer to allow the stabilizer to reach the carburetor. Do not drain the gas tank and carburetor if using fuel stabilizer. ENGINE OIL Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Customer Responsibilities section of this manual). CYLINDERS • Remove spark plug(s). • Pour one ounce of oil through spark plug hole(s) into cylinder(s). • Turn ignition key to "START" position for a few seconds to distribute oil. Replace with new spark plug(s). OTHER • Do not store gasoline from one season to another. • Replace your gasoline can if your can starts to rust. Rust and/or dirt in your gasoline will cause problems. • If possible, store your unit indoors and cover it to give protection from dust and dirt. • Cover your unit with a suitable protective cover that does not retain moisture. Do not use plastic. Plastic cannot breathe which allows condensation to form and will cause your unit to rust. IMPORTANT: NEVER COVER TRACTOR WHILE ENGINE AND EXHAUST AREAS ARE STILL WARM. 25