Sharp AR-162S AR-162S Operation Manual - Page 61
Material Safety Data Sheet - model
View all Sharp AR-162S manuals
Add to My Manuals
Save this manual to your list of manuals |
Page 61 highlights
MATERIAL SAFETY DATA SHEET Section 1. Product Identification Product: AR-201NT/T/FT/ST (Black Toner) Date Issued: Nov. 1, 2000 MSDS No. F-00991 Section 2. Supplier's Name and Address Sharp Corporation 22-22 Nagaike-cho, Abeno-ku, Osaka, Japan Local suppliers are listed below. Please contact the nearest supplier for additional information. (Country) U.S.A. Canada United Kingdom (Name and Telephone Number) Sharp Electronics Corporation Telephone number for information: 1-800-237-4277 Emergency telephone number: 1-800-255-3924 Sharp Electronics of Canada Ltd. Telephone number for information: 905-890-2100 Emergency telephone number: 1-800-255-3924 Sharp Electronics (U.K.) Ltd. Telephone number for information: 01923-474013 Section 3. Ingredients Ingredients Styrene-Acrylate copolymer Carbon black Iron oxide Metal Complex dye CAS No. 29497-14-1 1333-86-4 1309-38-2 {109125-51-1 109125-50-0 84179-66-8 Proportion > 88 % < 6.0% < 4.5% < 1.5% OSHA PEL Not listed 3.5mg/m3 Not listed 0.5mg/m3 ACGIH TLV Not listed 3.5mg/m3 Not listed 0.5mg/m3 Other Limits None None None None Section 4. Hazardous Identification (Emergency Overview) Toner is a fine, black powder possessing no immediate hazard. There are no anticipated carcinogenic effects from exposure based on animal tests performed using toner. When used as intended according to instructions, studies do not indicate any symptoms of fibrosis will occur. Section 5. Health Hazard Data Route(s) of Entry: Inhalation? Skin? Ingestion? Yes No Possible but very unusual. Health Hazards: Acute oral toxicity ------- LDL0 of this toner is over 2,000mg/kg. Mutagenicity The result of Ames test is negative. Carcinogenicity: In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible human carcinogen). This classification is given to chemicals for which there is inadequate human evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The classification is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon black at levels that induce particle overload of the lung. Studies performed in animal models other than rats did not show any association between carbon black and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation containing carbon black demonstrated no association between toner exposure and tumor development in rats. Chronic Effect: In a study in rats of chronic inhalation exposure to a typical toner, a mild to moderate degree of lung fibrosis was observed in 92% of the rats in the high concentration (16mg/m3) exposure group, and a minimal to mild degree of fibrosis was noted in 22% of the animals in the middle (4mg/m3) exposure group, but no pulmonary change was reported in the lowest (1mg/m3) exposure group, the most relevant level to potential human exposures. Signs and Symptoms of Exposure: Minimal irritation to respiratory tract may occur as with exposure to any non-toxic dust. Medical Conditions Generally Aggravated by Exposure: None Emergency and First Aid Procedures: Inhalation; Remove to fresh air. If effects occur, consult medical personnel. Eye; In case of contact, immediately flush eyes with water for 15 minutes. 59