2014 Ford Fusion Energi Owner Manual Printing 1 - Page 155

Fuel and Refueling 6. To close the fuel filler door, press the center rear edge of the fuel filler door and then release. The fuel door will latch closed. If the fuel fill inlet did not close properly, a Check Fuel Fill Inlet message may appear on the instrument cluster. At the next opportunity, do the following: 1. Safely pull off the road. 2. Put the vehicle in position P and switch the ignition off. 3. Open the fuel filler door and remove any visible debris from the fuel fill opening. 4. Insert the fuel fill nozzle, or the fuel fill funnel provided with the vehicle, several times to allow the inlet to close properly. This will dislodge any debris preventing the inlet from sealing. If this action corrects the problem, the message may not reset immediately. It may take several driving cycles for the message to turn off. A driving cycle consists of an engine start-up (after four or more hours with the engine off) followed by city or highway driving. Continuing to drive with the message on may cause the service engine soon lamp to turn on as well. Using the manual override lever WARNING The fuel system may be under pressure. Insert the fuel nozzle slowly. If you hear a hissing sound near the fuel filler door, do not refuel until the sound stops. Otherwise, fuel may spray out, which could cause serious personal injury. Note: The vehicle must be in positionP when using the manual override feature. E156032 Note: Hold the handle of the fuel filler nozzle higher while you insert the nozzle for easier access. 4. Slowly insert the fuel filler nozzle fully into the fuel system to open both doors. Leave the nozzle fully inserted until you have stopped pumping fuel. E154765 Note: Allow about five to ten seconds after pumping fuel before removing the fuel filler nozzle. This allows residual fuel to drain back into the fuel tank and not spill onto the vehicle. 5. After you have stopped pumping fuel, slowly remove the fuel filler nozzle. Note: A fuel spillage concern may occur if overfilling the fuel tank. Do not overfill the tank to the point that the fuel is able to bypass the fuel filler nozzle. The overfilled fuel may run down the drain located below and in front of the fuel filler door. 152