LiftMaster MEGA SLIDE-X MEGA SLIDE-X MSLXDCBB Manual - Page 2

Table Of Contents

Get LiftMaster MEGA SLIDE-X PDF manuals and user guides View all LiftMaster MEGA SLIDE-X manuals
Add to My Manuals
Save this manual to your list of manuals

Page 2 highlights

TABLE OF CONTENTS INTRODUCTION Carton Inventory 3 Manual Release 3 UL325 Model Classifications 4 Safety Installation Information 5 Recommended Site Layout Example 6 Safety Precautions for Roller Gates 7 Warning Sign Placement 7 Operator Overview 8 INSTALLATION Concrete Pad 9 Anchors 9 Conduits 9 Chain Installation 9 Safety Edge Installation 9 WIRING AND HOOKUP AC Power Hookup (120/230 Vac 10 Input Commands 1-8 (3-Button Control Station 11 Accessory Connections 12 Battery Installation 12 Master/Second Wiring 12 TIMERS AND MODE SELECTIONS S1 & S2 Fast Run Timer - S1 13 Mode Selections - S1 13 Close Timer - S2 13 Mode Selections - S2 13 ADJUSTWMEANTRS NING Right or Left Hand Operation 14 Limit Switch Adjustments 14 CAUTION Instant Reverse Device (IRD 14 RECEIVER Set Security Mode 15 Programming the Remote to the Receiver 15 To Erase All Remote Control Codes 15 OPERATION AND MAINTENANCE General Service 16 Battery Disposal 16 Battery Replacement 16 Battery Maintenance/Testing 16 Battery Handling/Storage 16 TROUBLESHOOTING AVERTISSEMENT Battery Checkout 17 Gate Not Operating 17 ATTENTION SUGGESTED LOOP SENSOR LOCATIONS Free Exit on Vehicle Approach 18 Entry With Access Control Device 18 Dual Direction as Entry and Free Exit 18 CONTROL BOARD LAYOUT Component Locations 19 REPAIR PARTS 20 ACCESSORIES 21 SAFETY ACCESSORIES FOR SECONDARY ENTRAPMENT PROTECTION 22 REPAIR PARTS AND SERVICE 22 WARRANTY 23 INSTALLATION CHECK OFF LIST 24 IMPORTANT NOTES • BEFORE attempting to install, operate or maintain the operator, you MUST read and fully understand this manual and follow all safety instructions. • DO NOT attempt repair or service of your commercial door and gate operator unless you are an Authorized Service Technician. WARNING Mechanical CAUTION WARNING WEleActRricNal ING WARNING CAUTION When you see these Safety Symbols and Signal Words on the following pages, they will alert you to the possibility of SERIOUS INJURY or DEATH if you do not comply with the warnings that accompany them. The hazard may come from something AVERTISSEMENT mechanical or from electric shock. Read the warnings carefully. When you see this Signal Word on the following pages, it will alert you to the possibility of damage to your gate and/or the gate operator if you do not comply with the cautionary statements that accompany it. ReadAthTemTcaErefNullyT. ION AVERTISSEMENT AVERTISSEMENT AVERTISSEMENT ATTENTION 2

  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
2
INTRODUCTION
Carton Inventory. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Manual Release
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
UL325 Model Classifications . . . . . . . . . . . . . . . . . . . . . . . . . .4
Safety Installation Information . . . . . . . . . . . . . . . . . . . . . . . . . 5
Recommended Site Layout Example
. . . . . . . . . . . . . . . . . . . .6
Safety Precautions for Roller Gates . . . . . . . . . . . . . . . . . . . . .7
Warning Sign Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Operator Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
INSTALLATION
Concrete Pad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Anchors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Conduits. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Chain Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Safety Edge Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
WIRING AND HOOKUP
AC Power Hookup (120/230 Vac)
. . . . . . . . . . . . . . . . . . . . .10
Input Commands 1-8 (3-Button Control Station). . . . . . . . . .11
Accessory Connections
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Master/Second Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
TIMERS AND MODE SELECTIONS S1 & S2
Fast Run Timer - S1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Mode Selections - S1. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Close Timer - S2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Mode Selections - S2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
ADJUSTMENTS
Right or Left Hand Operation . . . . . . . . . . . . . . . . . . . . . . . . . 14
Limit Switch Adjustments
. . . . . . . . . . . . . . . . . . . . . . . . . . .14
Instant Reverse Device (IRD). . . . . . . . . . . . . . . . . . . . . . . . .14
RECEIVER
Set Security Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Programming the Remote to the Receiver. . . . . . . . . . . . . . .15
To Erase All Remote Control Codes . . . . . . . . . . . . . . . . . . . . 15
OPERATION AND MAINTENANCE
General Service
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Battery Replacement
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Maintenance/Testing
. . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Handling/Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
TROUBLESHOOTING
Battery Checkout
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Gate Not Operating. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
SUGGESTED LOOP SENSOR LOCATIONS
Free Exit on Vehicle Approach . . . . . . . . . . . . . . . . . . . . . . . .18
Entry With Access Control Device
. . . . . . . . . . . . . . . . . . . . .18
Dual Direction as Entry and Free Exit. . . . . . . . . . . . . . . . . . .18
CONTROL BOARD LAYOUT
Component Locations
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
REPAIR PARTS
20
ACCESSORIES
21
SAFETY ACCESSORIES FOR SECONDARY
ENTRAPMENT PROTECTION
22
REPAIR PARTS AND SERVICE
22
WARRANTY
23
INSTALLATION CHECK OFF LIST
24
TABLE OF CONTENTS
Mechanical
Electrical
WARNING
WARNING
CAUTION
CAUTION
WARNING
WARNING
When you see these Safety Symbols and Signal Words on the
following pages, they will alert you to the possibility of
SERIOUS
INJURY
or
DEATH
if you do not comply with the warnings that
accompany them. The hazard may come from something
mechanical or from electric shock. Read the warnings carefully.
When you see this Signal Word on the following pages, it will
alert you to the possibility of damage to your gate and/or the gate
operator if you do not comply with the cautionary statements that
accompany it. Read them carefully.
IMPORTANT NOTES
•
BEFORE attempting to install, operate or maintain the operator,
you MUST read and fully understand this manual and follow all
safety instructions.
•
DO NOT attempt repair or service of your commercial door and
gate operator unless you are an Authorized Service Technician.