Home » Sharp Manuals » Mobile Phones » Sharp TM200 » Manual Viewer

Sharp TM200 Service Manual - Page 51

Interface, Vibration Motor & LED Driver, Sense Flip - drivers

Get Sharp TM200 PDF manuals and user guides

Add to My Manuals
Save this manual to your list of manuals

Page 51 highlights

I/F CN 䇭(1) Sound signal system Speaker YM762 Amplifier unit Internal Sound source unit microphone AIN1 Receiver OUT1 OUT3L OUT3R AIN3L AIN3R Monophonic AIN2 AD6535 CONFIDENTIAL (4) Interface External headphone External Microphone External headphone External Microphone Interface SW UART Analog Serial UART USB BU7880 (2) LCD & camera system Flash LED Backlight LED LTC3205 LCD Power souceIC BD6020 +BD6030 LCD controler I/F 㧗3.0V 㧗1.8V Series regulator 3.0V 1.8V 15V 8V CCD camera I/F (5) Vibration Motor & LED Driver M Vibration Motor LDO ON/OFF YM762 Key LED-Light AD6535 Typhoon AC charger Constant voltage Constant current (3) Battery charge system VDT reg OVP AD6535 Lithium ion Battery pack (6) Sense Flip Flip Sense TAPE SIDE Polar"S" Upper CAB N Magnet S Lower CAB Hall IC EW6671 AD6529 Hermes TM200 DIAGRAMS 4 - 5

Section	Page
SERVICING CONCERNS	2
CHAPTER 1. GENERAL DESCRIPTION	3
1. Specifications	3
2. Names of parts	4
3. Operation manual	4
[Optional Accessories]	4
CHAPTER 2. 1ADJUSTMENTS, PERFORMANCE CHECK, AND FIRMWARE UPGRADE	5
[1] SHARP Program Support Tool (SPST)	5
1. System requirements	5
2. Introduction	5
2-1. Functions	5
2-2. Installation	5
2-3. Starting up	5
3. Adjustments for TM200	6
4. Functions	7
4-1. Default setting	7
4-2. User data back-up	7
4-3. User data restore	7
4-4. Downloader	8
4-4-1. Introduction	8
4-4-2. Getting started	8
4-4-3. Rewriting MOT files	11
4-4-4. Error message list	15
4-5. RF calibration & check	15
4-5-1. Preparation	15
4-5-2. Default setting for the program.	16
4-5-3. RF calibration (Remove SIM card)	16
4-5-4. RF performance check (Insert SIM card)	16
n Troubleshooting list	21
4-6. RF Test tool	21
4-6-1. Requirements	21
4-6-2. Setup	22
4-6-3. Tests	22
n GSM900 Band	23
n DCS/PCS Band	23
4-6-4. Termination	24
4-6-5. Trouble information	24
4-7. Password reset	24
4-8. Performance check and adjustment	24
4-8-1. Main back light check	25
4-8-2. External back light check	25
4-8-3. Key back light check	25
4-8-4. LED check	25
4-8-5. Battery voltage check	25
4-8-6. SD read/write test	25
4-8-7. Vibrator test	25
4-8-8. Melody test	25
4-8-9. Audio test	25
4-8-10. Camera check	26
4-8-11. Memory check	26
4-8-12. LCD test	26
4-8-13. Temperature adjustment	26
4-8-14. Main display flicker adjustment	26
4-8-15. External display contrast adjustment	26
4-8-16. White defect correction	27
4-8-17. Black defect correction	27
4-9. ****mode release	28
5. Other tests	28
5-1. USB	28
5-2. Bluetooth	28
[2] Test points	29
[3] Troubleshooting	33
1. Power is not turned on.	33
3. No voice is heard from the earpiece.	35
17. SD (Memory) card is not recognized.	44
18. USB connection is impossible.	45
19. Bluetooth communication is impossible.	45
CHAPTER 3. DISASSEMBLY AND REASSEMBLY	46
A. Battery removal	46
B. Speaker removal	46
C. VIBrating motor removal	46
D. Backup battery removal	47
E. Main/LCD PWB unit removal	47
F. Sub LCD removal	47
G. Main LCD, BL flexible unit removal	48
H. Receiver and mic removal	48
CHAPTER 4. DIAGRAMS	51
(5) Vibration Motor & LED Driver	51
(6) Sense Flip	51
CHAPTER 5. SCHEMATIC DIAGRAM AND WIRING SIDE OF P.W.BOARD	52
[1] Notes on schematic diagram	52
[2] Types of transistor and LED	52
[3] Waveforms of circuit	53
n MAIN PWB_FRONT	60
n MAIN PWB_REAR	61
CHAPTER 6. OTHERS	66
[1] Function table of IC	66
n IC101 (LRS1B27): 5-LEVEL STACK MEMORY	66
n IC103 (AD6535): ANALOG BASEBAND	68
n IC106 (AD6529B): DIGITAL BASEBAND	70
n IC107 VHIEW6671++-1R (EW6671): HALL	72
n IC108 VHIR3112Q26-1L (R3112Q261A): VOLTAGE DETECTOR	72
n IC109 VHINJ287130-1L (NJM2871F03): 3.0 V REGULATOR	73
n IC111 VHIR116030B-1L (R1160N301B): REGULATOR	73
n IC703 VHIR116018B-1L (R116018B): 1.8 V REGULATOR	73
n IC113, 706 VHITC7SZ08A-1L (TC7SZ08A): AND GATE/LOGIC	73
n IC114 RH-IXA007AFZZL (HA1631S03CME): COMPARATOR	73
n IC115 VHIXC61CN27-1L (XC61CN27): REGULATOR	73
n IC116 VHIRQ5RW45B-1L (RQ5RW45B): 4.5 V REGULATOR	73
n IC502 VHIBU7870KN-1L (BU7870KN): USB CONTROLLER	74
n IC505 VHIXC620930-1L (XC620930): REGULATOR	74
n IC506 RUNTZA005AFZZL (UGNZ2): BLUETOOTH MODULE	74
n IC507 VHITC7SET00FU- (TC7SET00FU): LOGIC	75
n IC508 VHI817A30NB-1R (817A30NB): 3.0V REGULATOR	75
n IC509 VHILVC2G34P-1R (LVC2G34P): BUFFER	75
n IC701 VHIR116025B-1L (R116025B): 2.5V REGULATOR	75
n IC702 VHITK11131C-1R (TK11131C): REGULATOR	76
n IC704 (LR38863): DISPLAY CONTROLLER	76
n IC708 VHITK11130C-1R (TK11130C): REGULATOR	80
n IC801 VHIHD155155-1L(HD155155NP): RF	80
n IC802 RF3146	81
n IC804 VHIR5322N29-1L(R5322N002B): POWER SUPPLY	81
[2] Function table of Display	82
n LCD1000 RLCUB0048AF03: MAIN DISPLAY	82

Match case Limit results 1 per page

TM200

DIAGRAMS

4 – 5

CONFIDENTIAL

(4) Interface

(5) Vibration Motor & LED Driver

(6) Sense Flip

(2) LCD & camera system

(3) Battery charge system

Sound

source

unit

Amplifier

unit

Monophonic

Internal

microphone

AIN1

AIN3R

AIN3L

Speaker

Receiver

OUT1

OUT3R

OUT3L

AIN2

External

headphone

External

Microphone

YM762

AD6535

LCD controler

Power

souceIC

BD6020

+BD6030

LTC3205

Backlight LED

Flash LED

CCD camera

I/F

LCD

15V

1.8V

3.0V

Series

regulator

1.8V

3.0V

VDT

OVP

AC charger

Constant voltage

Constant current

AD6535

Lithium ion

Battery pack

reg

External headphone

External Microphone

(1) Sound signal system

USB

Analog

UART

Serial

I/F CN

BU7880

Interface SW

LDO

ON/OFF

YM762

AD6535

Typhoon

Key

LED-Light

Vibration Motor

Magnet

Hall IC

EW6671

AD6529

Hermes

TAPE SIDE

Polar"S"

Upper CAB

Lower

CAB

Flip Sense