Weber Summit Platinum D6 LP Owner Manual
Weber Summit Platinum D6 LP Manual
 |
View all Weber Summit Platinum D6 LP manuals
Add to My Manuals
Save this manual to your list of manuals |
Weber Summit Platinum D6 LP manual content summary:
- Weber Summit Platinum D6 LP | Owner Manual - Page 1
SUMMIT® GAS GRILL LP Gas Grill Owner's Guide #38026 YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL ƽ DANGER If you smell gas: 1. Shut off gas in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions must - Weber Summit Platinum D6 LP | Owner Manual - Page 2
use. See instructions in this manual for correct procedures. ƽ Do not operate the Weber® gas barbecue if there is a gas leak present. ƽ Do not use a flame to check for gas leaks. ƽ Combustible materials should never be within 24 inches of the top, bottom, back or sides of your Weber® gas barbecue - Weber Summit Platinum D6 LP | Owner Manual - Page 3
, U.S.A.;Kettle Configuration, Kettle Silhouette, Genesis, Flavorizer, Crossover, Flamgo, Performer, Rapidfire, Tuck 'N Carry, Jumbo Joe, Bar-B-Kettle, Master-Touch, Spirit, Grill Out, Summit, Platinum, 1-800-Grill-Out, Ranch, Matchless Flame, Zimbabwe; Weber, Kettle Configuration, Kettle Silhouette .® - Weber Summit Platinum D6 LP | Owner Manual - Page 4
Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper assembly can be dangerous. • Not for use by children. • If there are local codes that apply to portable gas grills LP cylinder under or near the Weber® gas barbecue. ƽ WARNING: The LP cylinder - Weber Summit Platinum D6 LP | Owner Manual - Page 5
INSTRUCTIONS 5 GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. ƽ WARNING: Do not move the Weber® gas contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com® Outside - Weber Summit Platinum D6 LP | Owner Manual - Page 6
6 GAS INSTRUCTIONS IMPORTANT LP CYLINDER INFORMATION Failure to follow these DANGER statements exactly may result in a fire causing death or serious injury. ƽ DANGER ƽ NEVER store a spare LP Cylinder under or near this barbecue. ƽ NEVER fill the tank beyond 80% full. Your Weber® gas grill is - Weber Summit Platinum D6 LP | Owner Manual - Page 7
on our web site. Log onto www.weber.com®. Do not use the barbecue. 8) When leak checking is complete, turn gas supply OFF at the source and rinse connections with water. 7 CHECK FOR GAS LEAKS ƽWARNING : The gas connections of your Summit® gas grill have been factory tested. We do however - Weber Summit Platinum D6 LP | Owner Manual - Page 8
8 GAS INSTRUCTIONS Put your fingers under the front edge you should recheck all fittings for leaks before using your Weber Gas Barbecue. Shipping and handling may loosen or damage a gas fitting. ƽ WARNING: Perform these leak checks even if your after checking for leaks. Make sure side burner is OFF. - Weber Summit Platinum D6 LP | Owner Manual - Page 9
the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www. weber.com®. 4) Side burner hose to manifold connection 5) Side burner hose to side burner connection, and sideburner valve to - Weber Summit Platinum D6 LP | Owner Manual - Page 10
of each igniter. GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust Preheating Preheating the grill before grilling is important. Light your Summit® gas grill according to the instructions in this Owner's Manual. Turn both - Weber Summit Platinum D6 LP | Owner Manual - Page 11
viewing the color indicator level line on the side of the tank scale. 1) Empty 2) Medium 3) Full SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate - Weber Summit Platinum D6 LP | Owner Manual - Page 12
12 GAS INSTRUCTIONS • Air must be removed from a new LP cylinder before the initial filling. Your LP dealer is equipped to do this. • The LP cylinder must be installed, transported and stored in an upright position. LP cylinders should not be dropped or handled roughly. • Never store or transport - Weber Summit Platinum D6 LP | Owner Manual - Page 13
INSTRUCTIONS 13 GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual grill before grilling is important. Light your Summit® gas grill according to the instructions in this Owner's Manual arrange the fire on either side of it. Using the right - Weber Summit Platinum D6 LP | Owner Manual - Page 14
14 OPERATING INSTRUCTIONS INDIRECT COOKING The Indirect Method is similar to roasting, but with the added benefits of that grilled texture, flavor, and appearance you can't get from an oven. To set up for Indirect cooking, gas burners are lit on either side of the food but not directly beneath it. - Weber Summit Platinum D6 LP | Owner Manual - Page 15
Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the gas from the LP cylinder. If this should occur, turn OFF the LP cylinder valve and burner control knobs. Then start over. MAIN BURNER LIGHTING 1 4 ,5 ,8 7 2 6 3 2 *The grill - Weber Summit Platinum D6 LP | Owner Manual - Page 16
position. Turn gas supply OFF at the source. MANUAL LIGHTING ƽ DANGER gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP tank valve and burner control knobs. Then start over. MAIN BURNER LIGHTING 1 4 ,5 ,7 6 2 3 2 *The grill - Weber Summit Platinum D6 LP | Owner Manual - Page 17
INSTRUCTIONS 17 ƽ DANGER When the "excess gas flow control" feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas ,7 6 2 3 2 *The grill illustrated may have slight differences than the - Weber Summit Platinum D6 LP | Owner Manual - Page 18
18 OPERATING INSTRUCTIONS SIDE BURNER LIGHTING INSTRUCTIONS LIGHTING WITH IGNITER ƽ DANGER Failure to open the lid while igniting the side burner, SUMMIT® B, C, D or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive 1 flame-up which - Weber Summit Platinum D6 LP | Owner Manual - Page 19
OPERATING INSTRUCTIONS 19 MANUALLY LIGHTING SIDE BURNER ƽ DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flameup which can cause serious bodily injury or death. MANUAL - Weber Summit Platinum D6 LP | Owner Manual - Page 20
Always grill with the lid closed to allow the smoke to fully penetrate the food. Light the smoker burner by following the instructions for fish recipes in the gas grill cookbook. Cook with the lid down according to the times indicated in charts or recipes. (1) SUMMIT® D Cleaning the smoker Before - Weber Summit Platinum D6 LP | Owner Manual - Page 21
INSTRUCTIONS 21 LIGHTING THE SMOKER BURNER 1 ƽ WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. 2 ,3 ,9 Replace using only Weber® authorized replacement hose. Contact the Customer Service - Weber Summit Platinum D6 LP | Owner Manual - Page 22
source. MANUALLY LIGHTING THE SMOKER BURNER ƽWARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative - Weber Summit Platinum D6 LP | Owner Manual - Page 23
, turn the burner control knob to OFF and wait 5 minutes to let the gas clear before you try again. 1 2 ,3 ,1 0 8 7 ,9 4 5 4 *The grill illustrated may have slight differences than the model purchased. SUMMIT® D TO EXTINGUISH Push down and turn each burner control knob clockwise to OFF position - Weber Summit Platinum D6 LP | Owner Manual - Page 24
24 OPERATING INSTRUCTIONS ROTISSERIE ASSEMBLY Parts required: rotisserie motor bracket(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and fork screws (4). 1) Install the motor bracket Attach the stainless steel motor bracket to the left side of the cooking box, using the 1/4-20 - Weber Summit Platinum D6 LP | Owner Manual - Page 25
Cooking Method. IMPORTANT SAFEGUARDS ƽWARNINGS • Read all instructions before using your rotisserie. • This rotisserie is . OPERATING 1) Remove rotisserie shaft from grill. Remove one spit fork. 2) Push onto the support rollers. 6) The rotisserie shaft should rotate so that the heavy side of the - Weber Summit Platinum D6 LP | Owner Manual - Page 26
Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. 1) Open the lid. 2) Remove the warming rack and the cooking grates from the cookbox. ƽDANGER: Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas - Weber Summit Platinum D6 LP | Owner Manual - Page 27
INSTRUCTIONS LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP each side of the food(see Grilling methods-Indirect grill illustrated may have slight differences than the model purchased. SUMMIT - Weber Summit Platinum D6 LP | Owner Manual - Page 28
Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. 1) Open the lid. 2) Remove the warming rack and the cooking grates from the cookbox. ƽDANGER: Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas - Weber Summit Platinum D6 LP | Owner Manual - Page 29
OPERATING INSTRUCTIONS 29 ƽWARNING: The burner control knobs must be in the OFF position before turning on the liquid propane 1 5,6 cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting - Weber Summit Platinum D6 LP | Owner Manual - Page 30
TROUBLESHOOTING PROBLEM Burners burn with a yellow or orange flame, in conjunction with the smell of gas , or flame is low Is LP fuel low or empty? in HIGH to "Lighting Instructions". Refill LP cylinder. Straighten problems cannot be corrected by using these methods, please contact the Customer Service - Weber Summit Platinum D6 LP | Owner Manual - Page 31
"Lighting Instructions". Straighten hose. If match lights burner, check igniter (see below). If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. SIDE BURNER - Weber Summit Platinum D6 LP | Owner Manual - Page 32
32 ROTISSERIE TROUBLESHOOTING PROBLEM Burner does not light. CHECK Did you hold the cylinder valve on slowly. Refer to "Lighting Instructions". If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on - Weber Summit Platinum D6 LP | Owner Manual - Page 33
Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas flow, and can cause the gas be cleaned, call Weber-Stephen Products Customer Service for replacement parts. - Weber Summit Platinum D6 LP | Owner Manual - Page 34
MAIN BURNER FLAME PATTERN The Weber® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern ports when cleaning. REPLACE MAIN BURNERS 1. Your Summit® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. - Weber Summit Platinum D6 LP | Owner Manual - Page 35
9. Disconnect the Thermocouple from the IR Burner valve. 35 10. Remove screws from the manifold assembly: (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. 11. Pull manifold assembly out from the manifold frame. (a ) (b ) (a (b ) 12. Lift - Weber Summit Platinum D6 LP | Owner Manual - Page 36
leak checked with a soap and water solution before using the grill. (See, "Check for gas leaks.") (2) (1) CROSSOVER® IGNITION SYSTEM OPERATIONS If the Customer (2 ) Service Representative in your area using the contact information on our web site. Log onto www.weber.com®. REPLACE IGNITER
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
 |
 |
±
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
±
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or use gasoline or other
flammable liquids or vapors within 25
feet (8m) of this appliance.
±
WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
±
WARNING: Do not try to light this
appliance without reading the "Lighting"
Instructions section of this manual.
YOU MUST READ THIS OWNERS GUIDE
BEFORE OPERATING YOUR GAS GRILL
38026 US 04/12/05
LP
US ENGLISH
SUMMIT
®
GAS GRILL
#38026
#38026
LP Gas Grill Owner’s Guide