Weslo Gym 1500 Uk Manual

Weslo Gym 1500 Manual

Get Weslo Gym 1500 PDF manuals and user guides View all Weslo Gym 1500 manuals
Add to My Manuals
Save this manual to your list of manuals

Weslo Gym 1500 manual content summary:

  • Weslo Gym 1500 | Uk Manual - Page 1
    & Fitness, Ltd. Unit 4 Revie Road Industrial Estate Revie Road Beeston Leeds, LS118JG UK email: [email protected] CAUTION Read all precautions and instructions in this manual before using this equipment. Save this manual for future reference. USER'S MANUAL Visit our website at www.iconeurope.com
  • Weslo Gym 1500 | Uk Manual - Page 2
    ADJUSTMENTS 14 WEIGHT RESISTANCE CHART 16 CABLE DIAGRAM 17 TROUBLESHOOTING AND MAINTENANCE 18 ORDERING REPLACEMENT PARTS Back Cover Note: the centre of this manual. Remove the PART IDENTIFICATION CHART and PART LIST/EXPLODED DRAWING before beginning assembly. WESLO is a registered trademark of
  • Weslo Gym 1500 | Uk Manual - Page 3
    illegible, or removed. WARNING: Before beginning this or any exercise program, consult your physician. This is especially important for persons over the age of 35 or persons with pre-existing health problems. Read all instructions before using. ICON assumes no responsibility for personal injury or
  • Weslo Gym 1500 | Uk Manual - Page 4
    Thank you for selecting the versatile WESLO® GYM 1500 weight system. The WESLO® GYM 1500 weight system offers a selection of benefit, read this manual carefully before using the weight system. If you have questions after reading this manual, please call our Customer Service Department at 08457 089
  • Weslo Gym 1500 | Uk Manual - Page 5
    until assembly is completed. • Tighten all parts as you assemble them, unless instructed to do otherwise. • As you assemble the weight system, make sure all small parts, use the PART IDENTIFICATION CHART at the centre of this manual. The following tools (not included) are required for assembly: •
  • Weslo Gym 1500 | Uk Manual - Page 6
    (19) over the indicated holes in the bracket on the Base (1). Insert the two Weight Guides (16) into the holes and attach them to the Base with an M10 x 155mm Bolt holes in the Top Weight (17). Slide the Top Weight onto the Weight Guides (16). Be sure the pin groove in the Top Weight is on the
  • Weslo Gym 1500 | Uk Manual - Page 7
    the crossbar on the Top Frame. Attach the Top Frame (4) to the Upright (3) with the Support Plate (86), two M10 x 70mm Bolts (64), and two M10 Nylon Locknuts (68). Attach the Top Frame (4) between the Weight Guides (16) with an M10 x 155mm Bolt (76), two M10 Washers (62), two 19mm Spacers (29
  • Weslo Gym 1500 | Uk Manual - Page 8
    1 68 Tube 6 69 Cage 75 Lubricate Welded Spacer 81 Cable Assembly 8 8. During steps 8 through 19, refer to the CABLE DIAGRAM on page 17 of this manual to verify proper cable routing. Locate the Long Cable (47). Wrap the Long Cable around a 90mm Pulley (44). Attach the Pulley to the Top Frame
  • Weslo Gym 1500 | Uk Manual - Page 9
    10. Wrap the Long Cable (47) around a "V"-Pulley (45). Attach the Pulley and a Long Cable Trap (46) to the bracket on the Left Butterfly Arm (9) with an M10 x 57mm Bolt (59) and an M10 Nylon Locknut (68). Be sure the Cable Trap is turned to hold the Cable in the groove of the Pulley. Repeat this
  • Weslo Gym 1500 | Uk Manual - Page 10
    14. Attach the Long Cable (47) to the Small "U"- 14 Bracket (24) with an M8 Nylon Locknut (58) and an M8 Washer (60). See the inset drawing. Do not overtighten the Nylon Locknut; it should be threaded onto the end of the Cable only two turns. 47 79 60 47 24 58 26 Attach the Small "U"-
  • Weslo Gym 1500 | Uk Manual - Page 11
    18. Wrap the Short Cable (48) around a 90mm Pulley 18 (44). Attach the Pulley and a pair of Pulley Covers (43) to the middle hole in the Upright (3) with an M10 x 98mm Bolt (78), an M10 Washer (62), and an M10 Nylon Locknut (68). Be sure the large tabs on the Pulley Covers are on the side
  • Weslo Gym 1500 | Uk Manual - Page 12
    21. Press two 38mm Square Inner Cap (53) into the Leg Lever (8). Attach the Seat Bumper (40) with an 21 M4 x 20mm Screw (84) and an M6 Washer (63). Lubricate the M10 x 62mm Bolt (87) with grease. Attach the Leg Lever (8) to the Seat Frame (5) with the Bolt and an M10 Nylon Locknut (68). Do not
  • Weslo Gym 1500 | Uk Manual - Page 13
    If one of the cables does not move smoothly, find and correct the problem. IMPORTANT: If the cables are not properly installed, they may be damaged this manual for proper cable routing. If there is any slack in the cables, you will need to remove it by tightening the cables; see TROUBLESHOOTING AND
  • Weslo Gym 1500 | Uk Manual - Page 14
    ADJUSTMENTS The instructions below describe how each part of the weight system can be adjusted. Refer to the exercise guide accompanying this manual to see how the weight system should be set up for each exercise. IMPORTANT: When attaching the accessories, make sure that they are in the correct
  • Weslo Gym 1500 | Uk Manual - Page 15
    with the M8 x 65mm Carriage Bolt (57) and the Seat Knob (21). For some exercises, the Seat (12) must be removed. First, be sure that the Chain (not , insert the Locking Bar (27) into the indicated hole in one of the Weight Guides (16) and secure the Locking Bar with the Lock (28). Remove the Lock
  • Weslo Gym 1500 | Uk Manual - Page 16
    at each weight station may vary due to differences in individual weight plates, as well as friction between the cables, pulleys, and weight guides. Note: 1 lb. = .454 kg. WEIGHT PLATES PRESS ARM (lbs.) BUTTERFLY ARM (lbs.) LEG LEVER HIGH PULLEY LOW PULLEY (lbs.) (lbs.) (lbs.) Top 28
  • Weslo Gym 1500 | Uk Manual - Page 17
    CABLE DIAGRAM The cable diagram below shows the proper routing of the Long Cable (47) and the Short Cable (48). Use the diagram to be sure that the two cables and the cable traps have been assembled correctly. If the cables have not been correctly routed, the weight system will not function properly
  • Weslo Gym 1500 | Uk Manual - Page 18
    TROUBLESHOOTING AND MAINTENANCE Make sure all parts are properly tightened each time the weight system is used. Replace any worn parts immediately. The weight Remove the cable and re-install it. If the cables need to be replaced, see ORDERING REPLACEMENT PARTS on the back cover of this manual. 18
  • Weslo Gym 1500 | Uk Manual - Page 19
    NOTES 19
  • Weslo Gym 1500 | Uk Manual - Page 20
    when ordering replacement parts: • the MODEL NUMBER of the product (WLEVSY19220) • the NAME of the product (WESLO® GYM 1500) • the SERIAL NUMBER of the product (see the front cover of this manual) • the KEY NUMBER and DESCRIPTION of the part(s) (see the PART LIST and EXPLODED DRAWING in the centre
  • Weslo Gym 1500 | Uk Manual - Page 21
    assembly. The number in parenthesis below each part refers to the key number of the part from the PART LIST in the centre of this manual. Important: Some parts may have been pre-assembled for shipping purposes. If you cannot find a part in the parts bags, check to see if it
  • Weslo Gym 1500 | Uk Manual - Page 22
    25mm Round Inner Cap (74) 25mm Square Inner Cap (54) 19mm Round Inner Cap (39) 25mm Retainer (50) 38mm Square Inner Cap (53) 25mm Cover Cap (49) 45mm Square Inner Cap (52) 50mm Square Inner Cap (51) 50mm Square Outer Cap (41)
  • Weslo Gym 1500 | Uk Manual - Page 23
    PART IDENTIFICATION CHART-Model No. WLEVSY19220 R1203A M6 Washer (63) M8 Washer (60) M10 Washer (62) M6 Nylon Locknut (61) M8 Nylon Locknut (58) M10 Nylon Locknut (68) M6 x 16mm Screw (67) M4 x 20mm Screw (84) M8 x 42mm Bolt (79) M10 x 45mm Bolt (82) M6 x 50mm Screw (70) M6 x 50mm Carriage Bolt (
  • Weslo Gym 1500 | Uk Manual - Page 24
    M10 x 195mm Bolt (75) M8 x 65mm Carriage Bolt (57) M10 x 65mm Carriage Bolt (56) M10 x 70mm Bolt (64) M10 x 73mm Bolt (80) M10 x 85mm Bolt (66) M10 x 90mm Bolt (83) M10 x 98mm Bolt (78) M8 x 117mm Bolt (77) M10 x 155mm Bolt (76)
  • Weslo Gym 1500 | Uk Manual - Page 25
    REMOVE THIS PART LIST/EXPLODED DRAWING FROM THE MANUAL. SAVE THIS PART LIST/EXPLODED DRAWING FOR FUTURE REFERENCE 81
  • Weslo Gym 1500 | Uk Manual - Page 26
    Plastic Bushing 82 2 M10 x 45mm Bolt 83 1 M10 x 90mm Bolt 84 1 M4 x 20mm Screw 85 1 Cable Trap 86 1 Support Plate 87 1 M10 x 62mm Bolt 88 1 Eyebolt # 1 User's Manual # 1 Exercise Guide Note: "#" indicates a non-illustrated part. Specifications are subject to change without notice.
  • Weslo Gym 1500 | Uk Manual - Page 27
    62 68 16 76 62 43 44 43 68 23 48 27 65 58 60 68 51 77 64 86 82 29 85 20 82 29 44 58 52 44 83 62 59 68 46 68 4 44 52 59 68 51 59 46 45 55 45 46 45 55 50 68 50 68 49 3 49 9 47 79 62 68 24 28 62 76 60 58 26 25 68 2 62 72 10 17 63 11 18 72 12 52 73 68 68 62 41
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
USER'S MANUAL
Model No. WLEVSY19220
Serial No.
Write the serial number in the
space above for reference.
Serial Number Decal
CAUTION
Read all precautions and instruc-
tions in this manual before using
this equipment. Save this manual
for future reference.
www.iconeurope.com
Visit our website at
QUESTIONS?
As a manufacturer, we are
committed to providing com-
plete customer satisfaction. If
you have questions, or if there
are missing parts, please call:
Or write:
ICON Health & Fitness, Ltd.
Unit 4
Revie Road Industrial Estate
Revie Road
Beeston
Leeds, LS118JG
UK
08457 089 009