Lenovo NetVista IBM PC300 (Type 2169) - Hardware Maintenance Manual (September
Lenovo NetVista Manual
View all Lenovo NetVista manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo NetVista manual content summary:
- Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 1
Hardware Maintenance Manual for Service Level A For Micro Tower Models Machine Type 2169 European Market Only i - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 2
OR FITNESS FOR A PARTICULAR PURPOSE. References to IBM products, programs, or services do not imply that IBM intends to make them available outside the United States. This publication could include technical inaccuracies or typographical errors. Changes are periodically made to the information - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 3
, Messages, Error Codes, or Beeps .... 74 Troubleshooting 87 Factory-Installed Storage Devices 88 Factory-Installed Modem Card 91 Audio (Not Supported by Diagnostics Program).......... 93 CD-ROM Drive 95 Memory 95 Keyboard 96 Mouse 97 Power Supply 99 Monitor 102 Undetermined Problems 104 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 4
Adapter Cards 115 Diskette Drive 117 CD-ROM Drive 118 Hard Disk Drive 119 System Board 119 Power Supply 121 Memory (DIMM 121 Introduction 123 Power Supply Cable Connector Specifications 129 Main Output Pin Assignment 130 Factory-Installed Modem Card Layout 132 Factory-Installed Modem Card - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 5
legally protectable rights, may be used instead of the IBM product, program, or service. References in this publication to IBM products, programs, or services are purely hardwarerelated and do not cover circumstances of software problems. Evaluation and verification of operation in conjunction with - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 6
of this product during an electrical storm. To avoid shock hazard: q The power cord must be connected to a properly wired and earthed receptacle. q Any must also be connected to properly wired receptacles. When possible, use one hand to connect or disconnect signal cables to prevent a possible shock - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 7
OFF. 2. First, attach all cables to devices. 3. Attach signal cables to receptacles. 4. Attach power cord(s) to outlet. 5. Turn device ON To Disconnect 1. Turn Everything OFF. 2. First, remove power cord(s) from outlet 3. Remove signal cables from receptacles. 4. Remove all cables from devices - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 8
Caution: When replacing the battery, use only IBM Part Number 36L9077 or an equivalent type battery recommended by the . Removing the covers of the CD-ROM drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the CD-ROM drive. Do not remove the CD-ROM - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 9
DANGER Some CD-ROM drives contain an embedded Class 3A or Class 3B laser diode. Note the or equipment damage, disconnect the attached power cords, telecommunications systems, networks, and modems before you open the covers, unless instructed otherwise in the installation and configuration procedures - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 10
PERIGO Para evitar choques elétricos, não conecte ou desconecte nenhum cabo, nem efetue instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. Para evitar choques elétricos: q O cabo de alimentação deve ser conectado a um receptáculo corretamente instalado e - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 11
Para Conectar Para Desconectar 1. DESLIGUE tudo. 1. DESLIGUE tudo. 2. Conecte primeiro todos os cabos nos dispositivos. 3. Conecte os cabos de sinal nos receptáculos. 4. Conecte o(s) cabo(s) de alimentação nas tomadas. 5. LIGUE o dispositivo. 2. Remova primeiro o(s) cabo(s) de alimentação das - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 12
cuidado: Ao substituir a bateria, utilize apenas o Número de Peça IBM 33F8354 ou um tipo de bateria equivalente recomendado pelo fabricante. Se seu sistema possuir um módulo com uma bateria de lítio, substitua-o apenas pelo mesmo - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 13
PERIGO Algumas unidades de CD-ROM contém um diodo de laser da Classe 3A ou da Classe 3B. Observe o seguinte. Radiação de laser quando aberto. Não olhe diretamente para o feixe de laser, não olhe diretamente com instrumentos óticos, e evite exposição direta ao raio. ≥32 Kg ≥55Kg (70,5 (121,2 lbs) - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 14
12 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 15
13 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 16
14 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 17
15 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 18
16 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 19
, lorsque vous installez ou que vous déplacez le présent produit ou des périphériques qui lui sont raccordés, reportez-vous aux instructions cidessous pour connecter et déconnecter les différents cordons. Connexion Déconnexion 1. Mettez les unités hors tension. 1. Mettez les unités hors tension - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 20
attention: Remplacez la pile usagée par une pile de référence identique exclusivement - voir la référence IBM - ou par une pile équivalente recommandée par le fabricant. Si votre système est doté d'un module contenant une pile au lithium, vous devez le - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 21
DANGER Certaines unités de CD-ROM contiennent une diode laser de classe 3A ou 3B. Prenez connaissance des informations suivantes : Rayonnement laser lorsque le carter est ouvert. Évitez de regarder fixement le faisceau ou de l'observer à l'aide d'instruments optiques. Évitez une exposition directe - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 22
ses cordons d'alimentation, ainsi que les câbles qui le relient aux réseaux, aux systèmes de télécommunication et aux modems (sauf instruction contraire mentionnée dans les procédures d'installation et de configuration). VORSICHT Aus Sicherheitsgründen bei Gewitter an diesem Gerät keine Kabel - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 23
an Steckdose 4. Alle Kabel von Einheiten anschließen. lösen. 5. Gerät einschalten. achtung: Eine verbrauchte Batterie nur durch eine Batterie mit der IBM Teilenummer 33F8354 oder durch eine vom Hersteller empfohlene Batterie ersetzen. Wenn Ihr System ein Modul mit einer Lithium-Batterie enthält - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 24
achtung: Wenn ein CD-ROM-Laufwerk installiert ist, beachten Sie folgendes. Steuer- und Einstellelemente sowie Verfahren nur entsprechend den Anweisungen im vorliegenden Handbuch einsetzen. Andernfalls kann gefährliche Laserstrahlung auftreten. Das Entfernen der Abdeckungen des CD-ROM-Laufwerks kann - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 25
VORSICHT Manche CD-ROM-Laufwerke enthalten eine eingebaute Laserdiode der Klasse 3A oder 3B. Die nachfolgend aufgeführten Punkte beachten. Laserstrahlung bei geöffneter Tür. Niemals direkt in den Laserstrahl sehen, nicht direkt mit optischen Instrumenten betrachten und den Strahlungsbereich meiden. - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 26
PERICOLO Per evitare il pericolo di scosse elettriche durante i temporali, non collegare o scollegare cavi, non effettuare l'installazione, la manutenzione o la riconfigurazione di questo prodotto. Per evitare il pericolo di scosse elettriche: q collegare il cavo di alimentazione ad una presa - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 27
Quando si sostituisce la batteria, utilizzare solo una batteria IBM o batterie dello stesso tipo o di tipo equivalente utilizzo di controlli, regolazioni o l'esecuzione di procedure non descritti nel presente manuale possono provocare l'esposizione a radiazioni pericolose. L'apertura di un'unità CD - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 28
PERICOLO Alcune unità CD-ROM contengono all'interno un diodo laser di Classe 3A o Classe 3B. Prestare attenzione a quanto segue: Aprendo l'unità vengono emesse radiazioni laser. Non fissare il fascio, non guardarlo direttamente con strumenti ottici ed evitare l'esposizione diretta al fascio. ≥32 Kg - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 29
27 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 30
28 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 31
29 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 32
PELIGRO Para evitar una posible descarga eléctrica, no conecte ni desconecte los cables ni lleve a cabo ninguna operación de instalación, de mantenimiento o de reconfiguración de este producto durante una tormenta eléctrica. Para evitar una posible descarga: q El cable de alimentación debe - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 33
caution: Al cambiar la batería, utilice únicamente la batería IBM Número de pieza 33F8354 o un tipo de batería equivalente recomendado por el fabricante. Si el sistema tiene un módulo que contiene una batería de litio, - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 34
PELIGRO Algunas unidades de CD-ROM tienen incorporado un diodo de láser de Clase 3A o de Clase 3B Tenga en cuenta la siguiente información. Cuando la unidad está abierta se generan emisiones de rayos láser. No dirija la mirada al haz, no lo observe directamente con instrumentos ópticos y evite la - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 35
/DVD-ROM drive in the computer is a laser product. The CD/DVD-ROM drive's classification label (sample shown below) is located on the drive. CLASS 1 and Human Services 21 Code of Federal Regulations (DHHS 21 CFR) Subchapter J for Class 1 laser products. In other countries, the drive is certified to - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 36
IBM OS/2 Personal System/2 PS/1 PS/2 Intel, Pentium, MMX, EtherExpress, and LANDesk are trademarks or registered trademarks of Intel Corporation. Microsoft, MS-DOS, Windows, and Windows NT are trademarks or registered trademarks of Microsoft Corporation. Other company, product, and service - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 37
chapters: Notices contains important safety information and notices required to service this computer. General Information contains a brief description of this manual. Check Procedures provide step-by-step instructions that aid in locating the failure Field Replaceable Unit (FRU). Diagnostic - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 38
Information General Information 36 Introduction 37 Product Overview 37 Hardware Interfaces 40 41 Flash (BIOS) Update Procedure 42 BIOS-contained Model Number and Serial Number .......... 43 BIOS Setup Utility 44 Working with the Setup Menus 44 Specifications 63 Operating Requirements 64 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 39
sockets. − 32-MB, 64-MB, 128MB or 256-MB DIMM. − Maximum memory is 256MB. External Ports • Video port (15-pin D-sub connector) • Parallel port (25-pin D-sub connector) • Serial port (9-pin D-sub connector) • Game/MIDI port (15-pin D-sub connector) • Keyboard port (6-pin PS/2 mini-din connector) 37 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 40
• 512 KB cache buffer in hard disk drive. CD-ROM Drive • 5.25-in. high-performance, 40X CD-ROM IDE/AT drive. • Read data and play audio from standard and mini CD-ROM and audio compact discs (audio CDs). Multimedia • One pair of external speakers (Not all models). Power Management • Compliant to ACPI - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 41
− Windows 98 power utility timer elapses − System sleep timer elapses Power Supply • 150-watt switchable high/low voltage power supply. • Standard SFX power supply with +5V and +3.3V standby power Internal Cabling • 40-pin ribbon cable for CD-ROM and ATA-66 cable for hard disk drive. • One 34-pin - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 42
cards Hard Disk Drives CD-ROM Drive Diskette Drive Video Modem Audio Pointing device Keyboard device drive Support Bootable CD-ROM Format specification version 1.0. AT diskette interface Physical interface is compatible with the IBM Personal System/2 (PS/2) VGA interface. Intel 810 VGA on board. One - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 43
Table 1-1 Item USB System Board Hardware Interfaces Interface USB controller integrated in core logic chip set. 41 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 44
BIOS source code binary file. 2. Insert the diskette and boot from drive A. WARNING: Do not boot with any memory related driver update the system bios. 6. The program updates the BIOS automatically. 7. Wait for the update to complete. WARNING: Do not turn off the system power while the BIOS - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 45
BIOS: 1. Prepare a bootable DOS diskette with VPD.EXE files. 2. Insert the diskette and boot from drive A. WARNING: Do not boot with any memory related driver if you want to update the Machine Type Model, type Y to continue. When the screen shows: MTM: Follow the instructions on the screen to - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 46
hardware. Working with the Setup Menus Starting the Setup Utility Follow these steps to enter Setup when the computer is off: 1. Turn on your monitor. 2. Turn on the system unit. 3. When you see the IBM logo, press DEL to enter Setup and display the Main Menu. Refer to the Setup Utility Main - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 47
The following table lists specific keys on the keyboard that will help you move through the Setup menus: Keys Down- or up-arrow key Page Up or Page Down keys F1 Function Use these - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 48
system will automatically detect and configure any IDE devices it finds. If it fails to find a hard disk, change the value to Manual and then manually configure the drive be entering the characteristics of the drive in the items below (Capacity, Cylinder, Head, Precomp, etc.), If you have no device - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 49
. CPU L2 Cache ECC Checking Default: Enabled This item enables or disables ECC (Error Correction Code) error checking on the CPU cache memory. We recommend that you leave this item at the default value. Quick Power On Self Test Default: Enabled You can enable this item to shorten the - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 50
item is enabled, it checks the geometry of the floppy disk drives at start-up time. You don't need to enable this item unless you have a old diskette drive with 360K capacity. Boot Up NumLock Status Default: On This item defines if the keyboard Num Lock key is active when your system is started - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 51
you have installed more than 64 MB of memory and you are running the OS/2 operating system. Otherwise, leave this item at the default Non-OS2. Report No Diskette Drive for Win 95 If you are running a system with no floppy drive and using the Windows 95 OS, select Yes for this item to - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 52
introduce fatal errors or recurring memory. We recommend that you leave these items at the default value. System BIOS Cacheable Default: Enabled Video BIOS Cacheable Default: Enabled These items allow the video and/or system to be cached in memory write buffer to support delay transaction - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 53
support up to two separate drives. These drives have a master/slave relationship which is determined by the cabling configuration used to attach them to the controller. PIO means Programmed Input/Output. Rather than have the BIOS issue a series of commands to effect a transfer to or from the disk - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 54
transfers can improve the access to IDE devices. Enable this item if your IDE devices support block mode transfers. Onboard FDC Controller Default: Enabled Use this item to turn on or off the floppy disk controller that is built into this System Board. Onboard Serial Port 1 Default: 3F8/IRQ4 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 55
parallel port. If you are connected to a parallel device that supports the higherperformance EPP (enhanced parallel port) or the ECP (extended is enabled, the system will automatically resume when power is restored after an interruption in the power supply. Game Port Address Default: 201 This item - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 56
to RAM - the system shuts down with the exception of a refresh current to the system memory. Power Management Default: Define This item acts like a master switch for the power-saving modes and hard disk timeouts. If this item is set to Max Saving, powersaving modes occur after a short timeout - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 57
Power Management item, you can set this item to a selection of timeouts from 1 to 15 minutes. The hard disk drive will power down if the selected timeout passes without any activity on the hard disk add-in card in one of the PCI slots to resume the system from a power-saving mode. Power On by Ring - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 58
, the system will restart the power-saving timeout counters when any activity is detected on any of the drives or devices on the primary or S3. If your computer appears to have stopped and will not wake up from standby, press and hold the power switch for 5 seconds. Your computer will exit standby - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 59
If you encounter a problem with Standby Mode S3, set this option to S1 and check to see if updated device drivers that support Standby Mode S3 are available for your adapters. 57 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 60
configuration data stored in the BIOS setup is cleared from memory. New updated data is created. Resources Memory Length to set the amount of reserved memory. Press Esc to close the Memory Resources sub-menu. PCI/VGA Palette Snoop Default: Disabled This item is designed to overcome some problems - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 61
On mainboards which support hardware monitoring, Detect DIMM/PCI Clk Default: Disabled When this item is enabled, BIOS will disabled the clock signal of free DIMM and PCI slots. items appear if you have set the CPU Internal Core Speed to Manual. Use the CPU/DIMM/PCI Clock to set the system bus - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 62
Load Optimized Defaults Option This option opens a dialog box that lets you load optimized defaults for all appropriate items in the whole setup utility. From the main menu, highlight the option Load Optimized Settings, then press Enter. A dialog box appears confirming you want to load the default - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 63
you do not type the correct password, you cannot enter Setup. 6. If you set up a system password, you must type this password each time you power on your system. Save And Exit Setup Option Highlight this item and press Enter to save the changes that you have made in the setup - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 64
Erasing a lost or forgotten password (clearing CMOS) To erase a forgotten password, or clear a corrupted CMOS: 1. Turn off the computer and all attached devices. 2. Unplug the power cord. 3. Remove the cover. See "Removing the cover" on page 114. 4. Refer to the system board diagram on page 124 to - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 65
(width x depth x height): • System unit: For machine type 2169: − 380 (h) x 196 9w) x 360 (d) Weight: • System unit: For machine type 2169: − 7.6Kg Environment: • Temperature for system unit: − Power on: 10° to 35°C − Power off: 10° to 43°C • Humidity for system unit: − Power on: 8% to 80% − Power - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 66
Operating Requirements All machines require two power inputs: one on the system unit and one on the monitor display. The system unit comes with a voltage selector switch, allowing selection of either 115 V ac or 230 V ac. This switch must be - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 67
Special Tools The following special tool is required to service this system when running the diagnostics program (PC-Doctor): • Wrap plug, P/N 72X854 65 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 68
, Messages, Error Codes, or Beeps .... 74 Troubleshooting 87 Factory-Installed Storage Devices 88 Factory-Installed Modem Card 91 Audio (Not Supported by Diagnostics Program).......... 93 CD-ROM Drive 95 Memory 95 Keyboard 96 Mouse 97 Power Supply 99 Monitor 102 Undetermined Problems 104 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 69
(FRUs) most likely to cause a particular problem. Check Procedures: When the Start check procedure or the Index of Symptoms, Messages, Error Codes, or Beeps tables point you to a specific check procedure, proceed to that section. If there are any notes or instructions at the top of the page, read - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 70
on a separate hard drive partition. The recovery CD and Enhanced Diagnostics diskette are not shipped with the machine or the HMM. To download diagnostics tests or to order a recovery CD, see "Enhanced Diagnostics download" or diskette. IBM PC Enhanced Diagnostics The IBM PC Enhanced Diagnostics - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 71
available on-line at http://www.ibm.com/ • Select Support. • Select Desktop computing from the "Search by Category" pull down menu. How to Diagnose Combined FRUs: If an adapter or device consists of more than one FRU, any of the FRUs might cause an error code. Before replacing the device or adapter - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 72
-installed modem adapter card and any other IBM factory-installed adapter cards. q Disconnect any drives except: q 3.5-in. diskette drive q Hard disk drive q Factory-installed devices (such as a CD-ROM drive) q Make sure that all power cords and cables are connected properly. q Make sure - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 73
, messages, error codes, or beeps. q Make sure that there are no diskettes or CDs in the drives. 002 - DOES AN IBM LOGO SCREEN APPEAR DRIVE? (YES, READ AHEAD. NO, GO TO STEP 004.) q Follow the instructions on the screen and select Utility from the diagnostics program menu. q Select Tech Support - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 74
005 q If the keyboard responds incorrectly, go to "Keyboard" on page 96. 006 - DOES THE SYSTEM CONFIGURATION report shows only those devices supported by the diagnostics diskette. If a device is missing from the list and is not factory installed, refer to the service manual provided for that device. - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 75
"Power Supply Cable Connector Specifications" on page 129 and the layout of system board according the machine type in chapter 5. q Run the Diagnostics \ All Tests again. q If an error or other symptom is displayed, go to "Index of Symptoms, Messages, Error Codes, or Beeps" on page 74. q If no error - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 76
system files in the hard disk if these files are not found in the diskette or CD-ROM. NOTE: Remember that POST does not test all areas, but only those that allow the system to operate well enough to run the diagnostics program. Table 2-1 lists BIOS error codes, messages, and beeps to their possible - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 77
("Power Supply Cable Connector Specifications" on page 129 If the problem cannot be corrected by using the "BIOS Error Codes, Messages, And Beeps List" table and "Error Symptoms List" table, go to "Undetermined Problems" on page 104. Table 2-1 BIOS Error Codes, Messages, and Beeps List BIOS Error - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 78
replace memory module. System board. Make sure the keyboard is connected properly and are set correctly in BIOS Setup. System board. FLOPPY DISK(S) failure (40) Floppy Type mismatch. Hard disk(s) Diagnosis failure Make sure the hard disks are set correctly in BIOS setup. Hard disk drive cable - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 79
a problem, first find the BIOS error messages, codes, or beeps in left column. If directed to a check procedure, replace the FRU indicated in the check procedure. If no check procedure is indicated, the first Action/FRU listed in right column is the most likely cause. Secondary master hard disk - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 80
is the most likely cause. Beeps (2: long, 1: short) 2-1-1 2- (repeatedly) This code indicates that a video error has occurred and the BIOS cannot initialize the video screen to display any additional information. The code indicates that DRAM error has occurred. See "Memory (DIMM)" on page 121 to - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 81
requirement before diagnosing any processor problems. Processor fan does not run but power supply fan runs. Make sure that the system is not in power saving mode. With the system power on, measure the voltage of processor fan connectorr. (See "Power Supply Cable Connector Specifications" on page - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 82
mode when the Power Panel Power utility. Management is to Reload software from Recovery Enabled, and power partition. saving timer set in BIOS has elapsed. System hangs before system boot. "Index of Symptoms, Messages, Error Codes, or Beeps" on page 74. "Undetermined Problems" on page 104 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 83
in BIOS Setup, cable/jumper are set correctly before diagnosing any hard disk drive problems. Hard disk drive test failed. Load default settings. Hard disk drive cable. Hard disk drive. System board. Hard disk drive format Load default settings. error. Hard disk drive cable. Hard disk drive - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 84
. With the system power on, measure the voltage of hard disk LED connector CD-ROM Drive NOTE: Make sure CD-ROM drive is configured correctly in BIOS Setup, cable/jumper are set correctly and its laser beam is clean before diagnosing any CD-ROM drive problems. CD-ROM drive LED flashes for more - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 85
comes from speakers. Speaker power/connection/cable. Modem Data/fax modem software program invokes but cannot receive/send data/fax. "Factory-Installed Modem Card" on page 91. Video and Monitor Video memory test failed. Video adapter failed. Remove all non-factory cards. Load default settings - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 86
Symptoms Action/FRU NOTE: To diagnose a problem, first find the error symptom in the left column. If System board Parallel NOTE: Execute "Load BIOS Default Settings" in BIOS Setup to confirm ports' presence before diagnosing any parallel/serial ports problems. Serial or parallel port Make sure - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 87
. Load default settings. Diagnostics diskette. Memory module. System board. Missing diagnostics Diagnostics diskette. files(s). Keyboard Some or all keys on keyboard do not work. "Keyboard" on page 96. Power Supply Pressing power Press and hold power button for 4 secs switch cannot turn - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 88
. (Only pressing power switch can force system to turn off). Load default settings. Reload software from Recovery partition. No system power, or "Power Supply" on page 99. power supply fan is not running. System board. Other Problems Any other problems. "Undetermined Problems" on page 104 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 89
Troubleshooting Failing Parts or Assemblies: The check procedures generally help you trace a problem to one part or assembly. and are not repaired in the field. Measuring Voltages: Some check procedure steps instruct you to measure voltages on cable plugs and electronic board connectors. If you are - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 90
that the BIOS Setup Utility has the startup sequence set with diskette, CD-ROM, and hard disk drives. 001 - START q Insert the diagnostics diskette into the diskette drive. q Power-off then power-on the system unit. q Alternatively, if your machine has diagnostics programs on a recovery partition - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 91
settings. See "3.5-In. Hard Disk Drive Jumper Locations" on page 133 and "CD-ROM Drive" on page 95. q Check the voltages of all disk drive power connectors. See "Power Supply Cable Connector Specifications" on page 129. q Correct the parameter settings under Disk Drives in the BIOS Setup. q In the - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 92
q If an error or other symptom appears, go to "Index of Symptoms, Messages, Error Codes, or Beeps" on page 74. q If no error can be detected or the symptom is intermittent, go to "Undetermined Problems" on page 104. q End. 90 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 93
Factory-Installed Modem Card 001 - START q Power off the system unit. q In Windows 98 Device Manager, make q Power off the system unit. q Remove all adapter cards. q Connect a hard disk drive with pre-loaded Windows 98. q Power on the system unit. q Perform the following steps under Windows 98. - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 94
STEP 005.) q The modem adapter functions normally. q End. 005 q Make sure that Windows 98 is properly installed, then power off the system unit. q Plug the modem adapter card into a different PCI slot. q Go to step 002. q If the error symptom still remains, replace the modem adapter card. q End. 92 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 95
off the system unit. q Remove all adapter cards. q Connect a hard disk drive with pre-loaded Windows 98. q Power on the system unit. q Load default settings in setup (audio may be disabled). 002 - DO ANY POST MESSAGES, ERROR CODES, BEEPS, OR SYMPTOMS APPEAR? (YES, READ AHEAD. NO, GO TO STEP 003 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 96
instructions. 1. Start Microsoft Windows 98. 2. Select the Start icon. 3. Select Settings, then select Control Panel. 4. Select the Sound icon. 5. In the Sound window Exit Microsoft Windows 98. q If the symptom remains or has changed, go to "Index of Symptoms, Messages, Error Codes, or Beeps" on page - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 97
execute CD-ROM Test. 002 - DO YOU SEE A MESSAGE "NO CD-ROM DRIVE OR MSCDEX DEVICE DRIVER INSTALLED." ? (YES, READ AHEAD. NO, GO TO 003.) q Exit the diagnostics program and power off the system. q Check and make sure that the CD-ROM drive power cable and audio and data cables are not damaged and are - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 98
TO STEP 003) q Enter BIOS Setup Utility then reboot the system. Take note of any messages, error codes, or symptoms. If the error message remains, go to step 005. 003 q Follow the screen instructions to run the Memory test. 004 - DOES THE MEMORY TEST COMPLETE WITHOUT AN ERROR? (YES, READ AHEAD. NO - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 99
GO TO STEP 005.) q Power off the system unit. Carefully remove the grime and solve the stuck keys problem. q Go to step 001. 005 - ARE THERE ANY BROKEN PINS IN THE KEYBOARD PLUG? (YES, GO TO STEP 007. NO, READ AHEAD.) q Try with a known good keyboard. 006 - DOES THE ERROR SYMPTOM STILL REMAIN? (YES - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 100
READ AHEAD.) q Try with a known good mouse. 009 - DO THE ERROR SYMPTOMS STILL REMAIN? (YES, READ AHEAD. NO, GO TO STEP 010.) q Replace the system board. q End 010 q Replace the mouse. q End. 011 q Exit diagnostics program. q Make sure that the mouse driver is properly installed. q Go to step 002. 98 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 101
switch cable connectors from the system board and the power supply. q Disconnect the power connectors to all drives. q Connect the power connector to system board as a power load for driving up power supply. q Reconnect the power cord. 005 - DOES THE POWER SUPPLY FAN RUN? (YES, READ AHEAD. NO, GO TO - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 102
11 20 1 10 Power Supply Connectors (Bottom View) Hard Drive or CD-ROM End of Power Cable 3.5-In. Diskette Drive End of Power Cable 100 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 103
TO STEP 009) q The power supply is working normally. q If you suspect the on/off switch cable assembly, see Step 003. q If the fan continues to run when all connectors are plugged back in, go to "Undetermined Problems" on page 104. If the fan stops running when a drive connector is plugged back in - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 104
Windows 98. Use the operating system's video setup to change the monitor resolution. If the monitor type is set to the power line voltage, power cord, 001 - START q Power off the system Make sure that the power cords are properly connected drive. q Power on the monitor, and wait 20 seconds. q Power - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 105
STEP 004) q You have successfully completed the video diagnostics tests. If the problem remains, go to "Index of Symptoms, Messages, Error Codes, or Beeps" on page 74. q End. 004 q Power off the system unit. q Remove the hard disk drive system cable. q Power on the system unit. 005 - IS THE SCREEN - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 106
q Hard disk drive q DIMM q Processor q System board 4. Power on the system unit. 5. Repeat steps 1 through 4 until you find the failed device or adapter. 6. If software related, reload software from service partition. If the symptom changes, go to "Index of Symptoms, Messages, Error Codes, or Beeps - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 107
Diagnostic Aids Diagnostic Aids 105 Introduction 106 Power-On Self Test 106 Diagnostics Tools 107 Diagnostics Program Features 108 105 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 108
time you power-on the system, the power-on self test (POST) is initiated. Several items are tested during POST, but is for the most part transparent to the user. POST checks the following: • System Board • Memory • SVGA Controller • Hard Disk Drive(s) • Floppy Diskette Drive(s) • Keyboard • Mouse - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 109
downloaded form the IBM web. Performing a partial or full recovery Attention: The Product Recovery program on the hidden hard disk drive partition will overwrite all files on the C:\ drive only. A full recovery will restore the operating system, device drivers, and applications. A partial recovery - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 110
power button for at least four seconds, unplug the power cord and wait a few seconds before reconnecting it. 4. Turn on your computer. 5. Wait for the prompt, To start the Product Recovery System Test • Memory Test • Hard Disk Test • Floppy Disk Test • All Tests • Keyboard • Video • Internal Speaker - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 111
Onboard Ethernet • USB Port • System Configuration • Memory Contents • IRQ and DMA Use • Device Drivers • COM and LPT Ports • Physical Disk Drives • Logical Disk Drives • VGA Information • Software Interrupts • SCSI Devices • I/O Use • IDE Drive Info • Network Information • PCMCIA Information • PCI - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 112
Repairing Information 110 Removals and Replacements of machine type 111 Identifying the Parts of the System Unit 112 Top Cover 114 Adapter Cards 115 Diskette Drive 117 CD-ROM Drive 118 Hard Disk Drive 119 System Board 119 Power Supply 121 Memory (DIMM 121 ©11C0opyright IBM Corp. 2000 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 113
of machine type 2169 BEFORE REMOVING ANY FRU, POWER-OFF THE COMPUTER UNPLUG ALL POWER CORDS FROM ELECTRICAL OUTLETS, THEN DISCONNECT ANY INTERCONNECTING CABLES. ATTENTION: The System board, processors, adapter cards, DIMMs, and upgrade processors can be damaged by electrostatic discharge. Use - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 114
of the System Unit This computer system has 4 bays, each bay may have a factory-installed drive in it. The devices are 3.5" Diskette, 40X CD-ROM drive (some models only) and 5.0 GB hard disk (some models may have hard disk of 7.5 or 10 GB capacity). Diskette drives in this unit use the standard - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 115
1. CD-ROM Drive This machine has a factory-installed 40 X CDROM drive. 2. Power Supply 150Watt power supply 3. Diskette Drive This machine has a factory-installed 3.5" 1.44MB Floppy drive. 4. Hard Disk Drive This machine has a factory-installed 3.5" (5 min) GB hard disk drive. 5. CPU 6. Fansink 7. - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 116
components inside the frame before you touch the frame. Do not touch any of the components that have a voltage-warning label. q Disconnect the system unit power cord. 114 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 117
Adapter Cards Installing Adapter Cards q Remove the screw that secures the adapter card retainer and slot cover. Then remove the card retainer and slot cover. q Align and insert the adapter card into the adapter card connector. q Secure the card with the screw that you removed in the first step. q - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 118
Removing Adapter Cards Follow these steps to remove an adapter card: q Position the system unit so that the card is accessible to you. q If the adapter card has cables, disconnect them. Be sure to take note of where the cable is connected. You will have to reconnect these cables when you reinstall - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 119
: q Disconnect the power and signal cables from the back of the diskette and HDD drives. q Remove the single screw on the side of the cage q Remove the diskette mounting tray from the chassis as following illustration : q Slide the drive-mounting tray toward the rear of the computer and remove it - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 120
CD-ROM Drive To remove CD-ROM Drive: q Disconnect the power, sound and signal cables from the CD-ROM. q Remove the four screws (two on each side) that hold the CD-ROM drive to the chassis. q Open the door on the front of the computer. q Slide the CD-ROM drive forward through the front opening and - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 121
the hard disk drive: q Disconnect the power and signal cables from the back of the diskette and HDD drives. q Remove the single screw on the side of the cage q Remove the diskette mounting tray from the chassis as following illustration : Slide the drive-mounting tray toward the rear of the computer - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 122
board from the system: q To remove the system board. You must remove the adapter cards first. q Disconnect the power cable, CD-ROM cable, Diskette Drive cable, Hard Disk Drive cable, audio cable, power switch cable and LED cables from system board. q Remove the three screws on the back planar plate - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 123
This system has a 150-watt switching power supply. 1. To remove the power supply. You must remove the top cover first. 2. Disconnect the power cable from the riser board and all drives. 3. Remove the screws in the machine rear that secure the power supply. Memory (DIMM) This system has 2 system - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 124
board Layout Power Supply Cable Connector Specifications 129 Main Output Pin Assignment 130 Factory-Installed Modem Card Layout 132 Factory-Installed Modem Card Connector Functions .. 132 3.5-In. Hard Disk Drive Jumper Locations & Settings ........ 133 CD-ROM Drive 134 CD-ROM Drive Rear Panel - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 125
this information to help you locate parts such as electronic boards, connectors, pin numbers, and test points. This chapter also contains jumper settings for the hard disk drive, CD-ROM (compact disc-read-only memory) drive, and the connector information for modem adapter card. 123 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 126
PCI Slots Slot for a TV-Out/LCD Panel Riser card. Two slots for 168-pin SDRAM memory module Connector for floppy disk drives Primary and secondary IDE channels Connector for ATX power supply Connector for optional infrared port Panel connector for switches and indicators Connector for modem wake up - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 127
CDROM/DVD drive Auxiliary microphone and speaker out Chassis open detect connector Connector for two-color LED Clear CMOS memory jumper Function most of the power-consuming components except for the 3.3V required to refresh the memory. If LED1 is turned on, it warns you that the computer is still - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 128
connector. Pin 1 nearest to cpu Pin No. Function 1 GND. 2 +12V 3 SENSE t CAS FAN: Power FAN Connector. Pin 3 nearest to cpu Pin No. Function 1 GND. 2 +12V 3 SENSE t JP1 : Clear CMOS. Pin 1 marked on pcb Pin No. Function 1-2 close Normal operation ( - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 129
FOR SWITCHES AND INDICATORS The panel connector is used to implement the switches and indicators on your system case. Note: Only pins 15, 16 (Hard Disk Indicator) and pins 21, 22 (Power Switch) are used on 2169 standard models. Connector J2, referred to on the system board diagram is used for the - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 130
blade screwdriver under the edge of the retaining clip. 2. Turn the screwdriver one quarter turn, raising the clip while pressing down on the old battery with the + symbol facing out. 4. Insert a new 3V lithium battery IBM part number 33F8354 (battery type CR2032) into the socket and press it down - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 131
figures when checking for voltages on power supply cable connectors. When checking voltages, the power supply fan must be running. To power on the power supply without using the on/off switch, use a screwdriver or other tools to short the power supply connector (with the switch cable disconnected - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 132
Main Output Pin Assignment Pin Function Color 1 +3.3 V Orange 2 3.3 V Orange 3 COMMON BLACK 4 +5Vdc RED 5 COMMON BLACK 6 +5Vdc RED 7 COMMON BLACK 8 POWER GOOD GRAY 9 +5Vs PURPLE 10 +12Vdc YELLOW 11 3.3V Orange 12 -12Vdc BLUE 13 COMMON BLACK 14 P.S-on GREEN 15 COMMON - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 133
Hard Drive or CD-ROM Power Cable Connector 3.5-In. Diskette Drive Power Cable Connector 131 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 134
-Installed Modem Card Layout 1 2 Factory-Installed Modem Card Layout Factory-Installed Modem Card Connector Functions Item Function 1 Telephone line-out Some modem adapters may come without this jack. 2 Telephone line-in Connect to... Telephone set - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 135
3.5-In. Hard Disk Drive Jumper Locations & Settings 3.5-in Hard Disk (Quantum) Jumper Settings Locations Back of Drive (Quantum) AT Interface connector DS CS PK Master CS GND Defaul t Setting Jumper Configurations Slave Cable Select CS DS DS GND GND GND Jumper Shown - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 136
Drive CD-ROM Front Panel NOTE: Position of CD-ROM switches and LEDs may vary from illustration. Item 1 2 3 4 5 Description Load / eject button Headphone jack Power insert and press an eject-bar inside the emergency eject hole to manually eject the tray. A straightened paper clip with a diameter of - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 137
INPUT 1 2 5V G G 12V 5 4 3 2 1 CD-ROM Rear Panel Item Function 1 Power supply connector 2 IDE Connector 3 CD-ROM drive jumper settings 4 Audio out 5 Not Used Connect to... Power supply IDE channel on system board. -CD1 -- CD-ROM Drive Jumper Settings CS SL MA DESCRIPTION -- -- On - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 138
I/O Pin Signal Name I/O 1 Red Video O 9 +5 V dc N/A 2 Green Video O 10 Synch Ground N/A 3 Blue Video O 11 No Connection N/A 4 No 4 I/O Pin Signal Name I/O O 14 Auto Feed N/A I/O 15 Error I I/O 16 Initialize O I/O 17 Select (In) O I/O 18 Ground Power I/O 19 Ground Power 136 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 139
Ground I 23 Ground I 24 Ground I 25 Ground O Power Power Power Power Power Power Mouse Port Signals Pin Signal Name I/O Pin 1 Mouse Data I/O 4 2 No Connection N/A 5 3 Ground Power 6 Signal Name I/O +5 V dc Power Mouse Clock I/O No Connection N/A Keyboard Port Signals Pin Signal Name - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 140
24 Write GATE O 8 Index I 25 Ground N/A 9 Ground N/A 26 Track 0 I 10 No Connection N/A 27 Ground N/A 11 Ground N/A 28 Write Protect I 12 Drive Select 1 O 29 Ground N/A 13 Ground N/A 30 Read Data I 14 No Connection N/A 31 Ground N/A 15 Ground N/A 32 SIDE 1 SELECT O 16 Motor On - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 141
7 Host Data 5 I/O 27 I/O Channel Ready I 8 Host Data 10 I/O 28 No Connection N/A 9 Host Data 4 I/O 29 DMA Acknowledge O 10 Host Data 11 I/O 30 Ground Power 11 Host Data 3 I/O 31 Host IRQ I 12 Host Data 12 I/O 32 No Connection N/A 13 Host Data 2 I/O 33 Host A1 O 14 Host Data 13 I/O 34 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 142
Safety Inspection Guide Safety Inspection Guide 140 General Guidelines 141 ©Copyright IBM Corp. 2000 140 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 143
the hazard. All current IBM service supplements outlining feature/model changes, along with the machine history, should be reviewed. Check the following items: q Damaged, missing, or changed parts, especially in the area of the On/Off switch and the power supply. q Damaged, missing, or changed - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 144
- Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 145
Parts Catalog Part Catalog of machine type 144 Assembly 1: System Unit 144 Assembly 2: Diskette Drive, Hard Disk Drive 147 Assembly 3: CD-ROM, Modem Card 148 Assembly 4: Keyboard and Mouse 150 ©Copyright IBM Corp. 2000 143 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 146
Asm-Index FRU Number Description 1 See Assy 3 40x CD-ROM 2 11P7621 Power Supply 150W Asm 3 See Assy 2 Floppy Disk Drive 4 See Assy 2 HDD Drive 5 09N9307 INTEL Celeron 533MHz assy with fansink 6 06P2446 Fansink, Supports Celeron (non-PIII base) Processors 7 11P7551 ECS P6IWP-Fe i810 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 147
Cord Saudi Arabia Not Shown 14F0068 Power Cord Italy, Chile Not Shown 14F0033 Power Cord Arabic Not Shown 14F0086 Power Cord Israel Not Shown 11P7555 Top Cover Not Shown 11P7619 Drive Bay Panel, Bay 1 (5.25") Not Shown 11P7550 Chassis (w/o power supply ) Not Shown 11P7558 DASD Cage Not Shown - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 148
Not Shown Not Shown 11P7610 ECS Screw Kit (All screws except CD and HDD). 11P7610 IBM Screw Kit (for CD + HDD) Not Shown 11P7559 Chassis Feet 146 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 149
Assembly 2: Diskette Drive, Hard Disk Drive Asm-Index FRU Number Description 2-1 19K1583 5 GB Hard Disk Drive, 3.5" 2-2 11P7556 3.5", Diskette Drive 2-3 11P7554 HDD IDE Cable (DMA 66 MHz) 2-4 11P7553 FDD IDE Cable 147 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 150
Assembly 3: CD-ROM, Modem Card Asm-Index FRU Number Description 3-1 09N0879 40X CD-ROM, LG 3-1 19K1515 40XCD-ROM, LITEON 3-2 37L5098 CD-ROM IDE Cable 3-3 75H9219 CD-ROM Audio Cable (2169) 3-5 09N1676 Modem, 56K Data Fax, GVC EMEA/ANZ/India/Singapore 3-4 09N1626 Modem, 56K Data Fax, - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 151
Not Shown 60H6027 Modem Phone Cable Adapter Denmark Not Shown 60H6028 Modem Phone Cable Adapter Norway/Finland Not Shown 60H6029 Modem Phone Cable Adapter FR Not Shown 60H6030 Modem Phone Cable Adapter Germany Not Shown 60H6031 Modem Phone Cable Adapter +60H6023 UK/Northern Ireland Not - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 152
Assembly 4: Keyboard and Mouse 4-2 4-1 4-3 Asm-Index FRU Number Description 4-1 10L6145 IBM Mouse 4-2 37L2518 105 PALM REST ARABIC 275 4-2 37L2519 105 PALM REST, EURO BELGIUM/FR 120 4-2 37L2520 105 PALM REST, EURO BELGIUM/UK 120 4-2 37L2521 105 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 153
4-2 37L2529 105 PALM REST HUNGARIAN 208 4-2 37L2530 105 PALM REST ICELANDIC 197 4-2 37L2531 105 PALM REST, EURO ITALY 142 4-2 37L2532 105 PALM REST, EURO NORWEGIAN 155 4-2 37L2533 105 PALM REST POLISH 214 4-2 37L2534 105 PALM REST PORTUGUESE 163 4-2 37L2535 105 PALM REST ROMANIAN - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 154
online resources including several Internet World Wide Web sites, the IBM Online HelpCenter support areas, and a Fax-Back service. The IBM Automated Fax-Back System offers a variety of IBM computer-related articles. To access this service, call 800-IBM3395. The Fax-Back system file library can - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 155
USB port, 41 F Fan Error Symptoms 79, 99 H Hard Disk Drive 38, 119 3.5-In. Jumper Locations & Settings, 133 32-bit Access, 40 Check Procedure, 88 Error Symptoms, 81 PIO Mode, 51 Hard Disk Drive, 40 I IDE Connector Signals, 139 J Joystick, 40, 108 Error Symptoms, 85 K Keyboard, 39 Check Procedure, 96 - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 156
Card, 148 Diskette Drive, Hard Disk Drive, 147 Keyboard and Mouse, 150 System Unit, 144 Parts/Test Point Locations, 122 PCI, 40 PIO Mode, 51 Plug and Play,5 POST, 68 Power Consumption, 63 Power Management, 38, Power Supply, 39 Check Procedure, 99 ctor Specifications, 125 Error Symptoms, 85 Processor - Lenovo NetVista | IBM PC300 (Type 2169) - Hardware Maintenance Manual (September - Page 157
Printed in U.K International Business Machines Corporation Old Orchard Road, Armonk, New York 10504 Part Number: 11P7604 Date: 7/00
i
Hardware Maintenance Manual
for Service Level A
For Micro Tower Models
Machine Type 2169
European Market Only