2015 Kawasaki MULE PRO-FXT Owners Manual

2015 Kawasaki MULE PRO-FXT Manual

Get 2015 Kawasaki MULE PRO-FXT PDF manuals and user guides View all 2015 Kawasaki MULE PRO-FXT manuals

2015 Kawasaki MULE PRO-FXT manual content summary:

  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 1
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 2
    Quick Reference Guide This Quick Reference Guide will assist you in finding the information you're looking for. GENERAL INFORMATION BREAK-IN HOW TO OPERATE SAFE OPERATION MAINTENANCE AND ADJUSTMENT TRANSPORTING AND STORAGE TROUBLESHOOTING GUIDE j j j j j j j A Table of Contents is included
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 3
    Whenever you see the symbols shown below, heed their instructions! Always follow safe operating and maintenance practices. DANGER DANGER indicates a hazardous related to personal injury. ○NOTE indicates information that may help or guide you in the operation or service of the vehicle. NOTE
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 4
    WARNING Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 5
    of this vehicle change depending upon cargo load and driving modes. Read the Owner's Manual Read and understand this Owner's Manual. This is especially important for inexperienced drivers. Refer to this Owner's Manual if you have any questions. Off-Highway Use Only This vehicle is not an all
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 6
    Wearing Seat Belts Both the operator and passenger(s) should always wear their seat belts properly. Seat belts cannot completely protect you in every accident, but in many cases a seat belt can reduce the risk of serious injury. Also, to avoid injury, do not put any part of your body outside of the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 7
    EMISSION CONTROL INFORMATION To protect the environment in which we all live, Kawasaki has incorporated crankcase emission (1), exhaust emission (2) and evaporative emission (3) control systems in compliance with applicable regulations of the United States Environmental Protection Agency and
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 8
    the owner of this vehicle, you have the responsibility to make sure that the recommended maintenance is carried out according to the instructions in this Owner's Manual at your own expense. You should keep a maintenance record for your vehicle. To assist you in keeping this record, we have provided
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 9
    its features, capabilities, and limitations. To ensure a long, trouble-free life for your Mule, give it the proper care and maintenance described in this manual. For those who would like more detailed information on their Mule, a Service Manual is available for purchase from any authorized Kawasaki
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 10
    TABLE OF CONTENTS SPECIFICATIONS...SERIAL NUMBER LOCATIONS ...LOCATION OF PARTS ...LOCATION OF LABELS...LOADING INFORMATION ...GENERAL INFORMATION ...Multifunction Meter ...Speedometer:...Fuel Level Gauge Symbol: ...Clock: ...Odometer: ...Trip Meters A/B:...Hour Meter: ...2WD/4WD Indicator:...Red
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 11
    ...Fuse ...Breaker...General Lubrication ...Cleaning ...Bolt and Nut Tightening ...TRANSPORTING AND STORAGE ...Transporting the Vehicle...Storage...TROUBLESHOOTING GUIDE...YOUR WARRANTY/OWNER SATISFACTION ...ENVIRONMENTAL PROTECTION ...MAINTENANCE RECORD ... 133 134 134 135 135 135 135 137 138
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 12
    SPECIFICATIONS 11 SPECIFICATIONS PERFORMANCE Maximum Torque Minimum Turning Radius Differential Mode: Seating Capacity DIMENSIONS Overall Length Overall Width Overall Height: Wheelbase Tread: Ground Clearance Dry Mass: KAF820A KAF820B KAF820C KAF820D Curb Mass: KAF820A KAF820B KAF820C KAF820D Front
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 13
    12 SPECIFICATIONS Cargo Bed (L × W × H) Long bed mode 1 085 × 1 363 × 279 mm (42.72 × 53.66 × 10.98 in.) Short bed mode 560 × 1 363 × 279 (22.05 × 53.66 × 10.98 in.) ENGINE Type Displacement Bore × Stroke Compression Ratio Starting System Cylinder Numbering Method Firing Order Carburetion System
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 14
    SPECIFICATIONS 13 DRIVE TRAIN Driving Type: Transmission Type Primary Reduction Ratio Final Reduction Ratio: Overall Drive Ratio: Front Rear Forward Reverse Transmission Gear Ratio: Forward Reverse Front Final Gear Case Oil Front Final Gear Case Oil Capacity Transmission Case Oil Transmission Case
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 15
    14 SPECIFICATIONS Caster Tire Size: Rim Size: Fuel Tank Capacity ELECTRICAL EQUIPMENT Battery Headlight High Beam: Low Beam: Brake/Tail Light LOAD CAPACITY Maximum Vehicle Load (Including occupants, cargo and accessories) Maximum Cargo Bed Load Except for California Model: California Model: Except
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 16
    SERIAL NUMBER LOCATIONS 15 SERIAL NUMBER LOCATIONS The engine and frame serial numbers are used to register the vehicle. They are the only means of identifying your particular machine from others of the same model type. These serial numbers may be needed by your dealer when ordering parts. In the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 17
    16 LOCATION OF PARTS LOCATION OF PARTS (6-persons mode) 1. Headlights 2. LED Sub Headlight (KAF820C/D) 3. Front Access Cover 4. ROPS (Roll Over Protective Structure) 5. Steering Wheel 6. Front Seat 7. Front Seat Belts 8. 9. 10. 11. 12. 13. 14. 15. Rear Seat Rear Seat Belts Screen Lock Arm Cargo
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 18
    LOCATION OF PARTS 17 (3-persons mode) 1. 2. 3. 4. 5. Tailgate Latch Handle Tailgate Sun Top Roof (KAF820C) Screen Handgrip for Front Center Seat Passenger 6. Handgrip for Front Right Seat Passenger 7. Tail/Brake Light 8. Rear Shock Absorber 9. Cargo Bed Side Plate 10. Air Cleaner 11. 12. 13. 14.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 19
    18 LOCATION OF PARTS 1. Parking Brake Lever 2. Selectable DIFF-LOCK Shift Switch 3. Selectable 2WD/4WD Shift Switch 4. Headlight Switch 5. LED Sub Headlight Switch (KAF820C/D) 6. Multifunction Meter 7. Power Outlet Sockets 8. Glove Compartment 9. Cupholders 10. Steering Wheel Tilt Lock Lever (
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 20
    LOCATION OF LABELS 19 LOCATION OF LABELS All warning labels which are on your vehicle are repeated here. Read labels on your vehicle and understand them thoroughly. They contain information which is important for your safety and the safety of anyone else who may operate your vehicle. Therefore, it
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 21
    20 LOCATION OF LABELS 5. 6. 7. 8. 9. Specification (ROPS) Notice (No Storage Area) Specification (Model) Danger (Radiator Cap) Brake Fluid Warning
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 22
    LOCATION OF LABELS 21 10. Danger/Poison (Battery) 11. Warning (Refueling) 12. Warning (Cargo Bed Lifting: both sides)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 23
    22 LOCATION OF LABELS 13. 14. 15. 16. Warning (Trailer Towing) Important Information (Air Cleaner) Important Information (Drive Belt) Power Outlet Socket Information (KAF820C/D)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 24
    LOCATION OF LABELS 23 17. 18. 19. 20. Warning (Cargo Bed Operation) Warning (Cargo Bed Loading) Certification (Emission) Important Information (Tires/Max. Load)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 25
    24 LOCATION OF LABELS 21. Instruction (Rear Seat)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 26
    LOCATION OF LABELS 25 (1) (2) (3)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 27
    26 LOCATION OF LABELS (4) (7) (8) (5) (6)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 28
    LOCATION OF LABELS 27 (9) (11) (10) (12)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 29
    28 LOCATION OF LABELS (13) (14) (15)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 30
    LOCATION OF LABELS 29 (16) (KAF820C/D) (17) (18) (Except for California Model)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 31
    30 LOCATION OF LABELS (18) (California Model Only) (19)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 32
    LOCATION OF LABELS 31 (20) (Except for California Model) (20) (California Model Only)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 33
    32 LOCATION OF LABELS (21)
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 34
    in an unsafe operating condition. Before you operate it, make sure that the vehicle is not overloaded and that you have followed these instructions. With the exception of genuine Kawasaki Parts and Accessories, Kawasaki has no control over the design or application of accessories. In some cases
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 35
    34 LOADING INFORMATION NOTICE The front body work and fenders are not designed to carry cargo or to support your weight. They may break. subtract trailer tongue weight from the • Always Maximum Load capacity. Refer to the "Trailer Hitch Bracket" section in the "GENERAL
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 36
    GENERAL INFORMATION 35 GENERAL INFORMATION Multifunction Meter 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. Red CVT Belt Check Indicator Light Yellow Engine Warning Indicator Light Red EPS Warning Indicator Light Speedometer Fuel Level Gauge Red Parking Brake Indicator Light Red Reverse
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 37
    36 GENERAL INFORMATION Speedometer: The speedometer shows the speed of the vehicle. j A. mph·km/h Display B. Left Button C. Right Button A. Speedometer mph·km/h Display: mph·km/h Display can alternate between U.S. and metric modes (mph and km/h) in the digital meter. Make sure that mph or km/h is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 38
    GENERAL INFORMATION 37 fuel is consumed the segments go out accordingly. When the bottom segment is reached, it will begin blinking to warn of a low fuel level. When it begins blinking 6.8 liters (1.8 U.S. gal) of fuel remain. Fill the fuel tank as soon as possible because there is no reserve tank
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 39
    38 GENERAL INFORMATION j ○When NOTE the figures come to 999999, they are stopped and locked. A. Minute Display the Right button. Both the hour and minute • Push displays start blinking again. the Left button. The displays stop blinking • Push and the clock starts working. A. Odometer ○
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 40
    GENERAL INFORMATION 39 2WD/4WD Indicator: This Vehicle can be driven in either "2WD" or "4WD". When the selectable 2WD/4WD shift switch is in "4WD", the "4WD" indicator symbol will appear. After shifting there is a momentary delay before the indicators change. j A. Trip Meter A Hour Meter: The
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 41
    goes on when engine parts fail to function properly. If this light goes on, have your authorized Kawasaki dealer to check the vehicle for the problem. Red EPS Warning Indicator Light: The EPS warning indicator light will momentarily illuminate when the engine starts, then go off in a second if the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 42
    the ignition switch is turned on. ○If this warning indicator light does not go on when the ignition switch is turned on, there may be a problem with the light itself. Contact an authorized Kawasaki dealer for inspection. Red Parking Brake Indicator Light: When the parking brake is applied with the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 43
    42 GENERAL INFORMATION j Lighting/Electrical Accessory Socket The lighting/electrical accessory 12 volt sockets are located on the dashboard. On KAF820C/D models, the rear power outlet sockets are located on the footwell of the rear seat. An auxiliary light or an accessory may be connected to these
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 44
    GENERAL INFORMATION 43 j Light Switches The light switches are 3-position type with a pilot light which illuminates while the ignition switch is turned on. The headlights can be turned on by pushing the " or " " position headlight switch to the " when the ignition switch is in the "ON" position. :
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 45
    the fittings of steering actuator, or the neutral position setting of the steering will be adversely affected and will cause serious driving problems. If such components need service, contact an authorized Kawasaki dealer. If the steering becomes more difficult than usual or you feel a steering
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 46
    GENERAL INFORMATION 45 ○The power steering system functions only when engine is running. ○If you install wireless equipment on board, contact Steering Position Adjustment (KAF820B/C/D) NOTE j an authorized Kawasaki dealer. Installing such equipment improperly may affect the ECU. The steering
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 47
    46 GENERAL INFORMATION j Brake Pedal The brake pedal is the left pedal on the floor board. Depress the pedal to slow or stop the vehicle. Sun Top Roof (Equipped Model) The rear of the sun top roof can be raised and flipped forward after unhooking the rubber retaining straps on both sides so that
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 48
    GENERAL INFORMATION 47 NOTICE Do not drive the Mule with the rear of the sun top flipped forward as it could damage the hinge of the sun top roof. j Converting Rear Seat and Cargo Bed This vehicle can be converted to accommodate more passengers and less cargo or fewer passengers and more cargo.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 49
    48 GENERAL INFORMATION 2. Lift the rear seat by holding the handgrip on either side, and turn the rear seat forward. 3. Push the rear seat frame forward into the stored position. j A. Cargo Bed Latch (Both Sides) B. Handgrips C. Rear Seat Cushion D. Plastic Seat base A. Rear Seat Frame (Stored
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 50
    GENERAL INFORMATION 49 5. Turn the screen lock arms upward until lower locking arm is released from the lock pin in the cargo bed base. 6. Slide the cargo bed screen forward in conjunction with pushing the hinge between the cargo bed side plates on both sides. j A. Screen Lock Arm (Both Sides) B.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 51
    50 GENERAL INFORMATION 10. Close the rear doors. j ○Pull the screen lock arms lightly to check if they are locked securely. WARNING Failure to properly lock the cargo bed or screen may allow them to move suddenly while driving, causing loss of control and an accident resulting in serious injury or
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 52
    GENERAL INFORMATION 51 ○After folding the cargo bed side plates, push both NOTE WARNING Failure to properly lock the cargo bed or screen may allow them to move suddenly while driving, causing loss of control and an accident resulting in serious injury or death. To prevent the cargo bed from
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 53
    52 GENERAL INFORMATION j Cargo Bed Tailgate The tailgate of the cargo bed can be lowered. Before lowering the tailgate, park on a firm level surface and set the parking brake. To open the tailgate, release the latches and lower the tailgate. Cables hold the tailgate level with the cargo bed. A.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 54
    bed, park on a firm level surface and set the parking brake. Empty the cargo bed prior to raising the cargo bed. Support the bed in the tilted position with the supporting damper provided on the bottom of the cargo bed. Do not drive the vehicle with the front end of the cargo
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 55
    54 GENERAL INFORMATION 2. Lift the rear seat by holding the handgrip on either side, and turn the rear seat forward. 3. Push the rear seat frame forward into the stored position. j A. Cargo Bed Latch (Both Sides) B. Handgrips C. Rear Seat Cushion D. Plastic Seat base A. Rear Seat Frame (Stored
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 56
    the cargo bed. To avoid injury, grasp cargo bed at the handle and do not hold the ROPS when lifting or lowering the cargo bed. A. Supporting Damper B. Cargo Bed (Raised Position) C. Supporting Rod ○Do NOTE not hold ROPS when lifting or lowering the cargo bed. ○Using only the bed
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 57
    56 GENERAL INFORMATION Lifting the Cargo Bed in Extended Configuration 1. On models equipped with a sun top roof, unhook the rubber retaining straps on both sides, and raise the rear of the roof and flip it forward. 2. Open the rear doors. Make sure the screen lock arms are locked properly then
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 58
    not hold the ROPS when lifting or lowering the cargo bed. j ○Do 4. NOTE not hold ROPS when lifting or lowering the cargo bed. Pull the supporting rod out of its clip and attach the curved portion of the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 59
    can suddenly lower, trapping arms between the bed and frame causing serious injury. To prevent the bed from suddenly lowering, use the handles to properly support the bed when lowering or lifting the bed. On models equipped with a sun top roof, return the rear of the sun top roof to its
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 60
    GENERAL INFORMATION 59 failure to properly secure • Overloading, cargo, or improper use of the cargo bed WARNING j Fuel The fuel tank is mounted under the right side of the front seat. Use only fresh gasoline with the recommended octane rating from an uncontaminated source to insure proper running
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 61
    cause fuel pump and/or engine damage. table. The Antiknock Index is posted on service station pumps in the U.S.A. and Canada. The octane rating of a gasoline is a industry specifications may result in unsatisfactory performance. Operating problems that result from the use of poor quality or
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 62
    all fuel from the fuel tank. See the "STORAGE" chapter in this manual. j NOTICE Avoid using blends of unleaded gasoline and methanol (wood alcohol) whenever " containing more than 5% methanol. Fuel system damage and performance problems may result. Gasoline/Ether Blends - The most common ether is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 63
    62 GENERAL INFORMATION j Glove Compartment A glove compartment is provided at the right side of the dashboard. Store only light items to avoid damage to the inside of the compartment. Do not store items which must not get wet or dirty. Cupholders Cupholders are provided at the left and right sides
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 64
    GENERAL INFORMATION 63 Front Access Cover The front access cover can be removed for maintenance such as a coolant level inspection. the front access cover forward to disengage • Pull the tabs from the slits of the front hood. j NOTICE Do not store items under the front access cover. This area is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 65
    64 GENERAL INFORMATION j Ignition Switch This is a three-position, key-operated switch. The key can be removed from the switch only when it is in the "OFF" position. A. Front Access Cover B. Knob up the front ends of the access cover to make • Pull sure the cover is locked securely. WARNING An
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 66
    GENERAL INFORMATION 65 OFF ON Engine off. All electrical circuits off. All electrical equipment can be used. Hour meter works. j Keys This UV comes with two keys. Use one for the ignition switch and keep the other in a secure place to use as a spare. A key number is stamped on the key itself.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 67
    66 GENERAL INFORMATION you purchased your Kawasaki UV. It's possible the dealer may have the number in its records. If the key number is lost completely, you will need to replace the ignition switch. Contact your Kawasaki dealer to purchase additional spare keys either using your original key as a
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 68
    GENERAL INFORMATION 67 low gearing for maximum torque at low speeds, for climbing hills, pulling a trailer, or keeping constant low speeds. The high gearing raises the speed range for ordinary off-highway use. Stop the vehicle before moving the gear shift lever. j NOTICE Use of the high range for
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 69
    68 GENERAL INFORMATION j Selectable 2WD/4WD Shift Switch You can select "2WD" or "4WD" to suit various driving conditions. The selectable 2WD/4WD shift switch is located on the dashboard. A. "2WD" Indicator Symbol B. "4WD" Indicator Symbol Refer to the "Multifunction Meter" section in this
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 70
    GENERAL INFORMATION 69 NOTICE Shifting from "2WD" to "4WD" (or "4WD" to "2WD") when the vehicle is in motion could cause drive train damage. j Selectable DIFF-LOCK Shift Switch You can select differential "LOCK" (locked-rear axle) or "UNLOCK" (unlocked-rear axle) modes to suit various driving
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 71
    70 GENERAL INFORMATION j ○The NOTE DIFF-LOCK indicator light remains illuminated when the DIFF-LOCK shift switch is activated and the ignition switch is turned off. When the engine has not been started, the DIFF-LOCK indicator light will remain illuminated for approximately 5 ∼ 6 seconds. When
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 72
    GENERAL INFORMATION 71 Parking Brake Lever The parking brake lever is located at the left side of the steering wheel. Pull the lever rearward to apply the parking brake. To release, push in and hold the knob on the end of the lever and push the lever all the way forward. Spring pressure helps
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 73
    72 GENERAL INFORMATION j Doors Pull the door handle outward to open the door. Push or pull the door inward until the latch clicks to close the door. After closing the door, be sure to check that the latch is securely locked. If a door is damaged or does not close securely, contact an authorized
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 74
    GENERAL INFORMATION 73 Seats There are front and rear seats on this vehicle. It can be transformed from 3-persons to 6-persons by unfolding the rear seat. 3-Persons Mode 6-Persons Mode j A. Rear Seat ○Converting the rear seat must be made in comA. Rear Seat (Stored Position) NOTE bination
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 75
    74 GENERAL INFORMATION j Seat Belts The vehicle is equipped with retractable three-point seat belts for all occupants - operator and two passengers for the front seat and three passengers for the rear seat. Always wear the seat belts when operating and riding in the vehicle. WARNING Not wearing a
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 76
    GENERAL INFORMATION 75 4. Place the shoulder belt over your shoulder and across your chest. The shoulder belt should fit against your chest. If it is loose, pull the belt out all the way and then let it retract. j A. B. C. D. Seat Belt Latch Plate Buckle Red Button A. Lap Portion of Belt B.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 77
    76 GENERAL INFORMATION around both the occupant's waist and shoulder. Under rough driving situations the dual mode latch plate will lock the seat belt in place. To release the lock: Move the slider in the direction of the arrow mark. j Throttle Pedal The throttle pedal is the right pedal on the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 78
    GENERAL INFORMATION 77 j Trailer Hitch Bracket This vehicle is equipped with a bracket for a trailer hitch. Trailer towing equipment is not supplied with this vehicle. To avoid injury and property damage, observe the following precautions: WARNING Improper towing of a loaded trailer could cause an
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 79
    engine while the transmission is in neutral. ○It is important to perform the initial service after the first 20 hours or 200 km (120 mi) of operation as described in this manual and the service manual for this vehicle. See the Periodic Maintenance Chart in the "MAINTENANCE AND ADJUSTMENT" chapter
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 80
    If any irregularities are found during these checks, refer to the "MAINTENANCE AND ADJUSTMENT" chapter, see your dealer, or refer to the Service Manual for the action required to return the vehicle to a safe operating condition. j WARNING Failure to perform these checks before operation may result
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 81
    80 HOW TO OPERATE Tires ...Air pressure (when cold): Except for California Model: Tire Load Front Up to 748 kg (1 650 lb) Up to 590 kg (1 300 lb) Rear 590 ∼ 748 kg (1 300 ∼ 1 650 lb) Load Cold Tire Pressure 78.4 kPa (0.80 kgf/cm², 11.4 psi) 110 kPa (1.12 kgf/cm², 16.0 psi) 130 kPa (1.33 kgf/cm², 18
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 82
    HOW TO OPERATE 81 Steering ...Steering wheel free play 0 ∼ 20 mm (0 ∼ 0.79 in.). Action smooth without excessive play, rough spots, or strange noises. Brakes ...Check for braking effectiveness (while test running). Brake pedal free play 2 ∼ 10 mm (0.08 ∼ 0.39 in.). Brake fluid level between level
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 83
    82 HOW TO OPERATE Starting the Engine ○The vehicle is equipped with a starter lockout sys- NOTE DANGER Exhaust gas contains carbon monoxide, a colorless, odorless poisonous gas. Inhaling carbon monoxide can cause serious brain injury or death. DO NOT run the engine in enclosed areas. Operate
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 84
    clothing, wash the affected areas immediately with water for at least 5 minutes. Seek medical attention. A. Battery Cover the cargo bed and support it with the support• Lift ing rod. Refer to the "Cargo Bed" section in the Connecting Jumper Cables sure the ignition switch is turned off. • Make
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 85
    84 HOW TO OPERATE DANGER Batteries contain sulfuric acid that can cause burns and produce hydrogen gas which is highly explosive. Do not make this last connection at the fuel system or battery. Take care not to touch the positive and negative cables together, and do not lean over the battery when
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 86
    HOW TO OPERATE 85 the battery cover. Refer to the "Battery" • Reinstall section in the "MAINTENANCE AND ADJUST- • MENT" chapter. Lower the cargo bed and secure it with the latches. Refer to the "Cargo Bed" section in the "GENERAL INFORMATION" chapter. Moving Off sure that all doors are properly
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 87
    86 HOW TO OPERATE Braking Stopping the Engine NOTE the throttle pedal completely. • Release Put the gear shift lever into the "N" (Neutral) posi• tion. the parking brake to help prevent the vehicle • Apply from rolling. • Turn the ignition switch key to the "OFF" position. j ○When the throttle
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 88
    HOW TO OPERATE 87 Parking the Mule WARNING Operating or parking the vehicle near flammable materials can cause a fire, and can result in property damage or severe personal injury. Do not idle or park your vehicle in an area where tall or dry vegetation, or other flammable materials could come into
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 89
    88 HOW TO OPERATE WARNING Gasoline is extremely flammable and can be explosive under certain conditions, creating the potential for serious burns. Do not smoke. Make sure the area is well ventilated and free from any source of flame or sparks; this includes any appliance with a pilot light.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 90
    HOW TO OPERATE 89 NOTICE Shifting to high or low range when the vehicle is in motion could cause engine damage. Do not shift from "H" (High) or "L" (Low) to "R" (Reverse) and vice versa when the vehicle is moving or with the engine running above idling speed, or the transmission could be damaged.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 91
    90 HOW TO OPERATE Drive off slowly to allow "4WD" to engage or disengage. As it engages, the "4WD" indicator symbol will appear. ○It is normal to hear a small clanking noise when "4WD" engages or disengages while rolling on hard surfaces, such as hard-packed dirt. Shifting the Differential the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 92
    HOW TO OPERATE 91 WARNING Shifting to Locked-Axle Mode while turning or before entering a turn can reduce steering response, increasing the effort to turn. An unexpected change in direction can cause the operator to lose control, resulting in an accident and injury. Do not shift to Locked -Axle
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 93
    92 HOW TO OPERATE Catalytic Converter This vehicle is equipped with a catalytic converter in the exhaust system. The converter reacts with carbon monoxide, hydrocarbons and nitrogen oxides to convert them into carbon dioxide, water, nitrogen and oxygen resulting in much cleaner exhaust gases to be
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 94
    your vehicle may result in an unsafe operating condition. Before operation, make sure that the vehicle is not overloaded and that you have followed the instructions in the "LOADING INFORMATION" chapter.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 95
    94 SAFE OPERATION Driving in Reverse Start the engine following the procedure in the "Starting the Engine" section. Before shifting into reverse, stop the vehicle completely. Refer to the "Gear Shift Lever" in the "GENERAL INFORMATION" chapter and "Shifting Gears" section in the "HOW TO OPERATE"
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 96
    SAFE OPERATION 95 Turning the Vehicle The vehicle will turn in a smaller radius with the differential unlocked (in differential mode). In this mode, the rear wheels can turn at different speeds allowing the vehicle to turn tighter and more smoothly. Even in this mode, however, avoid sharp turns to
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 97
    96 SAFE OPERATION Climbing Hills Do not attempt to climb hills or steep inclines until you have mastered the controls and basic operating maneuvers of this vehicle. Always go straight uphill and, if the incline is steep and/or the surface is loose, use "4WD" with the differential locked for greater
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 98
    SAFE OPERATION 97 Descending Hills Slow down or stop at the top of a hill so you can pick a straight, safe path for descent to avoid any obstacles. Normally you should descend straight down a hill since driving at an angle could cause the vehicle to lean to one side and possibly tip over. Proceed
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 99
    98 SAFE OPERATION Traversing Hillsides When driving across the side of a hill, reduce vehicle speed and exercise extreme caution to prevent tipping or loss of control. Avoid hills with slippery sides that will cause you to lose traction. Also avoid traversing hillsides covered with rocks or other
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 100
    SAFE OPERATION 99 Driving through Water Avoid driving through water whenever it is possible. When driving across shallow water, choose a location to enter and exit the water where the banks are not too steep or slippery. Check before entering for rocks, holes or other obstacles which may cause you
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 101
    100 SAFE OPERATION Operator and Passenger Requirements All operators of this vehicle should possess a valid driver's license. The operator and passenger(s) must be able to place both feet flat on the floorboards while seated upright with their backs against the seatbacks when firmly holding the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 102
    SAFE OPERATION 101 This vehicle is designed for an operator and up to five passengers. Never carry persons in the cargo bed. Refer to the "LOADING INFORMATION" chapter before operating this vehicle. j
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 103
    in the HOW TO OPERATE chapter. D * j • ○ = Clean, adjust, lubricate, replace parts as necessary. = Service to be performed by an authorized Kawasaki Dealer or someone equally competent. = Service more frequently when operated in mud, dust, or other harsh driving conditions. = Emission Related
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 104
    MAINTENANCE AND ADJUSTMENT 103 FREQUENCY First Service Regular Service OPERATION ENGINE Every Every After 50 Every After 20 50 h, or 100 h, or 200 h, or h, or Every h, or 200 1 000 2 000 km 4 000 km 1 000
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 105
    104 MAINTENANCE AND ADJUSTMENT FREQUENCY First Service Regular Service Every Every After 50 Every After 20 50 h, or 100 h, or 200 h, or h, or Every h, or 200 1 000 2 000 km 4 000 km 1 000 year of
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 106
    MAINTENANCE AND ADJUSTMENT 105 FREQUENCY First Service Regular Service OPERATION Brake fluid - change Brake master cylinder cup and dust seal - replace Brake caliper piston seal and dust seal - replace Brake hoses - replace Brake fluid
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 107
    106 MAINTENANCE AND ADJUSTMENT FREQUENCY First Service Regular Service Every Every After 50 Every After 20 50 h, or 100 h, or 200 h, or h, or Every h, or 200 1 000 2 000 km 4 000 km 1 000 year of
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 108
    , accident, and injury. Check the oil level before each use and change the oil and filter according to the periodic maintenance chart in the owner's manual. j Oil Level Inspection the oil has just been changed, start the engine • If and run it for several minutes at idle speed. This fills the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 109
    the same an oil pan beneath the engine. • Place • Remove the drain bolt. • Oil and/or Oil Filter Change the cargo bed and support it with the support• Lift ing rod. up the engine thoroughly and then stop the • Warm engine. • Remove the oil filler cap. type and brand of oil that
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 110
    ] *Kawasaki Performance Oils and Lubricants have been specifically engineered for your vehicle. Consistent use of these products meets or exceeds warranty and service requirements and can help to extend the life of your Kawasaki. WARNING Engine oil is a toxic substance. Dispose of used oil properly
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 111
    110 MAINTENANCE AND ADJUSTMENT Front Final Gear Case Oil In order for the differential, pinion, and ring gears to function properly, check the oil level and change the oil in accordance with the Periodic Maintenance Chart. WARNING Vehicle operation with insufficient, deteriorated, or contaminated
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 112
    MAINTENANCE AND ADJUSTMENT 111 j A. Front Final Gear Case B. Oil Filler Cap A. Front Final Gear Case B. Filler Opening C. Bottom of Filler Opening NOTICE Be careful not to allow any dirt or foreign materials to enter the gear case. the oil level. The oil level should come to • Check the bottom of
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 113
    112 MAINTENANCE AND ADJUSTMENT Oil Change NOTE ○Before draining the oil, warm it up by running the vehicle. Warm oil drains easily and picks up any sediment. the vehicle level, place an oil pan beneath the • With gear case. • Remove the oil filler cap and drain plug. WARNING Gear case oil is a
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 114
    MAINTENANCE AND ADJUSTMENT 113 the oil filler cap and tighten it to the specified • Install torque. Tightening Torque Oil Filler Cap: 16 N·m (1.6 kgf·m, 12 ft·lb) Transmission Case Oil In order for the transmission, differential, pinion, and ring gears to function properly, check the oil level and
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 115
    114 MAINTENANCE AND ADJUSTMENT j A. Transmission Case B. Oil Filler Cap A. B. C. D. Slit Rib High Level Low Level NOTICE Be careful not to allow any dirt or foreign materials to enter the transmission case. the oil level is too high, remove the excess oil, • If using a syringe or other suitable
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 116
    MAINTENANCE AND ADJUSTMENT 115 Tightening Torque Oil Filler Cap: 20 N·m (2.0 kgf·m, 15 ft·lb) WARNING The exhaust system can get extremely hot during normal operation and cause serious burns. To avoid a serious burn, never touch a hot muffler or exhaust pipe during oil draining. Oil Change ○
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 117
    116 MAINTENANCE AND ADJUSTMENT Transmission Case Oil Capacity 2.0 L (2.1 US qt) the oil filler cap and tighten it to the specified • Install torque. Tightening Torque Oil Filler Cap: 20 N·m (2.0 kgf·m, 15 ft·lb) Cooling System WARNING The cooling system is pressurized and can get extremely hot
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 118
    MAINTENANCE AND ADJUSTMENT 117 Coolant Coolant absorbs excessive heat from the engine and transfers it to the air at the radiator. If the coolant level becomes low, the engine overheats and may suffer damage. Check the coolant level each day before operating the vehicle, and replenish coolant if the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 119
    118 MAINTENANCE AND ADJUSTMENT ○In an emergency you can add water alone to the NOTE coolant reserve tank, however it must be returned to the correct mixture ratio by the addition of antifreeze concentrate as soon as possible. NOTICE If coolant must be added often, or the reserve tank completely
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 120
    MAINTENANCE AND ADJUSTMENT 119 Spark Plugs The standard spark plug is shown in the table. The spark plug should be taken out periodically in accordance with the Periodic Maintenance Chart for cleaning and inspection. Spark plug cleaning and inspection should be done by an authorized Kawasaki dealer
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 121
    120 MAINTENANCE AND ADJUSTMENT Engine Air Cleaner A clogged engine air cleaner restricts the engine's air intake, increasing fuel consumption, reducing engine power, and causing spark plug fouling. ○If there is dust or mud around the battery and air cleaner housing, clean them using compressed air
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 122
    MAINTENANCE AND ADJUSTMENT 121 WARNING If dirt or dust is allowed to pass through into the fuel injection system, the throttle may stick or become inoperable resulting in a hazardous operating condition. ○Element installation is performed in the order of removal. NOTE reverse Element Cleaning
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 123
    122 MAINTENANCE AND ADJUSTMENT j A. B. C. D. Element Adapter Tabs Air Cleaner Housing A. Drain Hose B. Plug C. Battery the air cleaner housing cap securely. • Clamp Install the drain hose to the clamps. • Clean inside of the battery cover and install it (see • Battery Installation). there are any
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 124
    MAINTENANCE AND ADJUSTMENT 123 Spark Arrester This vehicle is equipped with a spark arrester approved for off-highway use by the U.S. Forest Service. It must be properly maintained to ensure its efficiency. Clean the spark arrester in accordance with the Periodic Maintenance Chart. WARNING An
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 125
    124 MAINTENANCE AND ADJUSTMENT DANGER Exhaust gas contains carbon monoxide, a colorless, odorless poisonous gas. Inhaling carbon monoxide can cause serious brain injury or death. Do not run the engine in enclosed areas. Operate only in a well-ventilated area. the engine. • Stop Install the new
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 126
    MAINTENANCE AND ADJUSTMENT 125 Tightening Torque Spark Arrester 13 N·m (1.3 kgf·m, 115 in·lb) Mounting Bolts Throttle Pedal If the throttle pedal has excessive play due to either cable stretch or misadjustment, it will cause a delay in throttle response, especially at low engine speed. Also, the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 127
    126 MAINTENANCE AND ADJUSTMENT Idle Adjustment Idle adjustment is controlled by the ECU (electronic control unit) and cannot be adjusted. If the idle speed is unstable or out of specification, have your authorized Kawasaki dealer inspect the fuel injection system. Specified Idle Speed: 1 050 ±50
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 128
    MAINTENANCE AND ADJUSTMENT 127 Fuel Hose Fuel hose and connections should be checked and replaced periodically by an authorized Kawasaki dealer in accordance with the Periodic Maintenance Chart. Fuel Tank Vent The fuel tank vent hoses must be routed as specified. The engine may stall or lose power
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 129
    128 MAINTENANCE AND ADJUSTMENT Belt Drive Transmission (CVT) This vehicle is equipped with a belt-driven Continuously Variable Transmission (CVT). This automatic drive system, although simple to operate, does require periodic inspection since the drive belt wears with normal use. Inspection should
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 130
    MAINTENANCE AND ADJUSTMENT 129 Excessive slippage will accelerate belt wear and lead to failure. Recognize these symptoms of excessive belt slippage. If excessive slippage occurs, do not continue to drive the vehicle until all damaged components are repaired. Smell of burning rubber. Visible white
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 131
    130 MAINTENANCE AND ADJUSTMENT There should be 2 ∼ 10 mm (0.08 ∼ 0.39 in.) • free play. of Use heavy-duty brake fluid only from a fresh, unopened container marked DOT4. Fluid Requirement WARNING Over time, brake fluid can absorb moisture, lowering its boiling point and reducing brake effectiveness
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 132
    MAINTENANCE AND ADJUSTMENT 131 WARNING Air in brake line can make the brake feel mushy or soft. This may cause reduced braking performance or brake failure and result in an accident. If brake lever travel is excessive or the brake feels mushy, have an authorized Kawasaki dealer inspect it
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 133
    132 MAINTENANCE AND ADJUSTMENT brake caliper, if the thickness of either pad is less than 1 mm (0.04 in.), replace both pads in the caliper as a set. Pad wear inspection and pad replacement should be done by an authorized Kawasaki dealer. Brake Light Switch When the brake pedal is depressed, the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 134
    MAINTENANCE AND ADJUSTMENT 133 Adjustment is best performed by an authorized • Adjustment Kawasaki dealer since the brake light switch is hard to adjust. Parking Brake Lever The parking brake helps hold the vehicle from rolling while parked. In accordance with the Periodic Maintenance Chart,
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 135
    the engine starts; inspect the battery voltage. Cable harness or connectors may have been disconnected. Contact an authorized Kawasaki dealer for service. • • • • ○If the steering becomes irregular or unusual for NOTE any reason other than above, have an authorized Kawasaki dealer check the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 136
    MAINTENANCE AND ADJUSTMENT 135 Wheels Rims The rims are a drop-center, tubeless tire design. Take care not to damage the sealing surfaces of the tire or rim when removing or installing tires. Note that the rims, like automotive rims, are not symmetrical. All wheels must be installed so that the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 137
    change or impair the handling of the vehicle. ○Installation of tubeless tires on rims requires compressed air and is normally recommended as a dealer service operation. Nevertheless, a tube can be inserted into the tire by the operator as an emergency repair. Use a tire pressure gauge to accurately
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 138
    MAINTENANCE AND ADJUSTMENT 137 Joint Boots In accordance with the Periodic Maintenance Chart, inspect the joint boots on the front axles, tie rod ends, steering knuckles, and rear axle shafts for cracks, holes, damage or deterioration. If there is any one of them, have the joint boot replaced by an
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 139
    138 MAINTENANCE AND ADJUSTMENT Suspension The spring adjusting sleeves on the shock absorbers have 5 positions so that the springs can be adjusted for different riding and loading conditions. On the California model, the rear shock absorbers are not adjustable. Shock Absorber Spring Force
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 140
    MAINTENANCE AND ADJUSTMENT 139 Spring Action (Front Shock Absorber) 590 ∼ 748 kg (1 300 ∼ 1 650 lb) Load (Except for California Model): PosiSpring SurSetting Load Speed tion Force face 1 2 (STD) 3 4 5 A. Adjusting Sleeve (Turn with a hook wrench) Weak | | ↓ Strong Soft ↑ | ↓ Hard Light ↑ | ↓
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 141
    140 MAINTENANCE AND ADJUSTMENT Spring Action (Rear Shock Absorber) 590 ∼ 748 kg (1 300 ∼ 1 650 lb) Load (Except for California Model): PosiSpring SurSetting Load Speed tion Force face 1 2 3 4 5 (STD) Weak | | ↓ Strong Soft ↑ | ↓ Hard Light ↑ | ↓ Heavy Good ↑ | ↓ Bad Low ↑ | ↓ High Seat Belts In
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 142
    MAINTENANCE AND ADJUSTMENT 141 are found, have the seat belt system checked or replaced by an authorized Kawasaki dealer. Cargo Bed Latches Depending on the cargo loading and/or passenger riding conditions, latch lever compression needs to be adjusted. Release the latch lever bolts and adjust the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 143
    142 MAINTENANCE AND ADJUSTMENT Headlight Beam Battery The battery is located under the right end of the rear seat. • • The headlight beams can be adjusted vertically. Remove the front access cover. Refer to the "Front Access Cover" section in the "GENERAL INFORMATION" chapter. Turn the adjusting
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 144
    MAINTENANCE AND ADJUSTMENT 143 j A. B. C. 1. 2. 3. 4. Battery Cover Latch Locking Tab Push the locking tab. Pull Slide Open A. B. C. 1. 2. 3. 4. Battery Cover Latch Locking Tab Push the locking tab. Pull Slide Open • Unlatch the latch as shown (left side). • Clear the hooks upward on the battery
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 145
    144 MAINTENANCE AND ADJUSTMENT j A. B. 1. 2. Hooks Battery Cover Slide Pull A. Battery Cover B. Tabs the tabs on the battery cover, and remove • Clear the battery cover right ward. ○If there is dust or mud around the battery and air cleaner housing, clean them using compressed air. NOTE •
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 146
    MAINTENANCE AND ADJUSTMENT 145 j A. Screws and Washers • Remove the battery holder. A. B. C. D. Battery Holder Red Cap (+) Terminal (-) Terminal the negative (-) cable from the (-) ter• Disconnect minal. the red cap. • Remove the positive (+) cable from the (+) ter• Disconnect minal. ○There is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 147
    146 MAINTENANCE AND ADJUSTMENT a visual inspection. Inspect for defective • Perform or cracked case and cover, and loose or damaged terminal posts or cables. Replace battery and/or cables immediately if any damage is found. Battery Installation that the rubber dampers on the battery • Check holder
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 148
    MAINTENANCE AND ADJUSTMENT 147 j A. Battery Cover B. Tabs C. Slots A. Battery Cover B. Tabs C. Slots • Insert the tabs into the slots as shown. • Lock the latch as shown.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 149
    148 MAINTENANCE AND ADJUSTMENT j A. B. 1. 2. Latch Battery Cover Close Pull A. Latch B. Battery Cover 3. Push WARNING Loose battery cables can create sparks which can cause a fire or explosion resulting in injury or death. Make sure the battery terminal screws are tightened securely and the covers
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 150
    MAINTENANCE AND ADJUSTMENT 149 installed in the battery for initial service. It is not necessary to check the battery electrolyte level or add distilled water. However, in order to maximize battery life and ensure that it
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 151
    . the battery from the vehicle (see Battery • Remove Removal). Battery Charging ○If you charge the sealed battery, never fail to observe the instructions shown on the label on the battery and charger. NOTE WARNING Battery posts, terminals and related accessories contain lead and lead compounds
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 152
    MAINTENANCE AND ADJUSTMENT 151 Fuse Fuses are arranged in the fuse boxes located in the front access cover. The main power fuses are located under the rear seat. If the electrical systems do not function, inspect the fuses. Before replacing a fuse, check the wiring harness and electrical equipment
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 153
    152 MAINTENANCE AND ADJUSTMENT j A. Fuse Boxes B. ECU Fuse Box A. Fuse Box Lids B. Fuses C. Main Fuse D. ECU Fuse E. Spare Fuses Open the fuse box lids and check the fuse element. If it is blown out, replace the fuse.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 154
    MAINTENANCE AND ADJUSTMENT 153 j Main Power Fuse A. Fuse Box • Remove the battery cover (see Battery Removal). Open the fuse box lid and check the fuse element. If it is blown out, replace the fuse. A. Battery Cover
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 155
    blown, steering becomes heavy. Replace the blown fuse with a fuse of the same specific amperage and type. If a replaced fuse blows again, there can be trouble with the ECU or harness/connectors. Contact an authorized Kawasaki dealer for inspection. You can check the 40 A fuse if it is blown at the
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 156
    MAINTENANCE AND ADJUSTMENT 155 Breaker The breaker for the radiator fan is located in the front access cover. If the fan does not function, inspect the breaker. In order to reset the breaker, push the button at the side of the breaker case. Before resetting, however, check that the radiator fan is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 157
    by an authorized Kawasaki dealer or perform it referring to the Service Manual for this vehicle. Cleaning To prolong the life of your vehicle in and around the vehicle chassis, engine, and exhaust can cause mechanical problems and increase the risk of fire. When operating the vehicle in conditions
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 158
    MAINTENANCE AND ADJUSTMENT 157 Before washing, precautions must be taken to keep water off the following parts. Muffler rear opening - cover with a plastic bag. Ignition switch - cover the key hole with tape. Preparation for Washing Avoid spraying water with any great force near the following
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 159
    158 MAINTENANCE AND ADJUSTMENT Bolt and Nut Tightening In accordance with the Periodic Maintenance Chart, have the tightness of the bolts, nuts, and fasteners checked by an authorized Kawasaki dealer. j
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 160
    TRANSPORTING AND STORAGE 159 TRANSPORTING AND STORAGE Transporting the Vehicle Note the following points the engine and remove the ignition switch • Stop key to prevent loss during transport. the vehicle to the transporter with a heavy • Fasten -duty strap or rope using tie down points on front [A]
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 161
    160 TRANSPORTING AND STORAGE Rear Tie Down Points Storage Preparation for Storage: Clean the entire vehicle thoroughly. Run the engine for about five minutes to warm the oil, shut it off and drain the engine oil. • • WARNING Engine oil is a toxic substance. Dispose of used oil properly. Contact
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 162
    AND STORAGE 161 ○As an alternative to draining the fuel system, a fuel stabilizer, such as STA-BIL, may be used. Follow the manufacturer's instructions for use. NOTE the battery, and store it where it will not • Remove be exposed to direct sunlight, moisture, or freezing temperatures. During
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 163
    162 TRANSPORTING AND STORAGE sure the spark plugs are tight. • Make the fuel tank with fuel. • Fill all the points listed in the "Daily Checks" • Check section in the "HOW TO OPERATE" chapter. as indicated in the "General Lubrication" • Lubricate section in the "MAINTENANCE AND ADJUSTMENT" chapter.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 164
    TROUBLESHOOTING GUIDE 163 TROUBLESHOOTING GUIDE Starter Motor Won't Turn Fuse failed (be sure to check for cause of failure) Battery cables do not make good electrical contact with battery terminals
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 165
    164 TROUBLESHOOTING GUIDE Selectable 2WD/4WD or DIFF-LOCK Systems Malfunction Actuators failed ECU failed Battery disconnected • • • j
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 166
    Am I Responsible For? You are responsible for maintaining your vehicle according to the maintenance schedule shown in this owner's manual. You are responsible for notifying your dealer immediately if there is a problem, and you, as the owner, will need to authorize the dealer to inspect the unit.
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 167
    , be sure to record your service in the Maintenance Record section of this Owner's Manual. Keep all receipts for the service and/or items necessary to perform vehicle if there is a failure, investigating the cause of the problem, and getting any needed authorization from Kawasaki if the repair is
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 168
    YOUR WARRANTY/OWNER SATISFACTION 167 How Do I Get Warranty Service? If there is a problem with your vehicle within the limited warranty period, you will need to schedule a service appointment and provide any maintenance records to an authorized Kawasaki dealer for inspection and diagnosis. You can
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 169
    ? This owner's manual should answer most of your questions about your Kawasaki. Your Kawasaki dealer should either be able to answer any other questions you might have immediately or be able to find the answer for you. Please send your correspondence to:. Consumer Services Kawasaki Motors Corp
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 170
    ENVIRONMENTAL PROTECTION 169 ENVIRONMENTAL PROTECTION Kawasaki subscribes to the guidelines of Tread Lightly! a program dedicated to protecting the great outdoors through education and fostering responsible enjoyment of public lands. When using your Kawasaki Utility Vehicle (UV), please follow
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 171
    170 MAINTENANCE RECORD MAINTENANCE RECORD Owner Name...Address ...Phone Number ...Engine Number ...Vehicle Number...Key Code ...Selling Dealer Name ...Address ...Phone Number ...Warranty Start Date ...Note: Keep this information and a spare key in a secure location. Date Traveled Distance
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 172
    MAINTENANCE RECORD 171 Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 173
    172 MAINTENANCE RECORD Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 174
    MAINTENANCE RECORD 173 Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 175
    174 MAINTENANCE RECORD Date Traveled Distance Maintenance Performed Dealer Name Dealer Address
  • 2015 Kawasaki MULE PRO-FXT | Owners Manual - Page 176
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
  • 122
  • 123
  • 124
  • 125
  • 126
  • 127
  • 128
  • 129
  • 130
  • 131
  • 132
  • 133
  • 134
  • 135
  • 136
  • 137
  • 138
  • 139
  • 140
  • 141
  • 142
  • 143
  • 144
  • 145
  • 146
  • 147
  • 148
  • 149
  • 150
  • 151
  • 152
  • 153
  • 154
  • 155
  • 156
  • 157
  • 158
  • 159
  • 160
  • 161
  • 162
  • 163
  • 164
  • 165
  • 166
  • 167
  • 168
  • 169
  • 170
  • 171
  • 172
  • 173
  • 174
  • 175
  • 176