Lenovo ThinkStation D20 Hardware Maintenance Manual
Lenovo ThinkStation D20 Manual
 |
View all Lenovo ThinkStation D20 manuals
Add to My Manuals
Save this manual to your list of manuals |
Lenovo ThinkStation D20 manual content summary:
- Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 1
ThinkStation Hardware Maintenance Manual Machine Type: 4105, 4155, 4157, 4158, 4217, 4218 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 2
- Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 3
ThinkStation Hardware Maintenance Manual Machine Type: 4105, 4155, 4157, 4158, 4217, 4218 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 4
it supports, be sure to read the information under Appendix A "Notices" on page 255. Twelfth Edition (March 2012) © Copyright Lenovo 2008, 2012. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software are delivered pursuant a General Services Administration "GSA" contract, use, reproduction - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 5
RAID (types: 4155, 4158, 4218 49 Installing SATA or SAS hard disk drives and configuring RAID 49 Installing SATA or SAS hard disk drives . . . 49 Entering the Marvell BIOS Setup to configure SATA or SAS RAID 49 Configuring the Marvell BIOS Setup to enable SATA or SAS RAID 0, 1, 5, or 10 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 6
Chapter 9. Symptom-to-FRU Index . . 53 Hard disk drive boot error 53 Power Supply Problems 53 Diagnostic error codes 54 Beep symptoms 71 POST error codes 72 Miscellaneous error messages 73 Undetermined problems 75 Chapter 10. Replacing FRUs (Type 4105, 4157, 4217 77 Locating controls and - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 7
Automatic configuration and power interface (ACPI) BIOS 253 Automatic Power-On features 253 Appendix A. Notices 255 Television output notice 256 Trademarks 256 Appendix B. System memory speed 257 Index 259 © Copyright Lenovo 2008, 2012 v - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 8
vi ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 9
. Before servicing a Lenovo product, be sure to read the Safety Information. See Chapter 2 "Safety information" on page 3. The Symptom-to-FRU Index and Additional Service Information chapters are not specific to any machine type and are applicable to all ThinkStation computers. This manual includes - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 10
date and expects its suppliers to be ready to support Lenovo's requirements and schedule in the EU. Products sold in June, 2006, failed RoHS compliant parts must always be replaced using RoHS compliant FRUs, so only the FRUs identified as compliant order. 2 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 11
the attached power cords, telecommunication systems, networks, and modems before you open the server/workstation covers, unless instructed otherwise in the installation and configuration procedures. Observe the following rules when working on electrical equipment. © Copyright Lenovo 2008, 2012 3 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 12
Power supply units - Pumps - Blowers and fans - Motor generators and similar units. (This practice ensures correct grounding of the units.) • If an electrical accident occurs: - Use caution; do not become a victim yourself. - Switch off power. - Send another person to get medical aid. 4 ThinkStation - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 13
machine, as it was designed and built, had required safety items installed to protect users and service personnel from injury. This guide addresses only those items. However, good judgment should be used to identify potential safety hazards due to attachment of features or options not covered by - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 14
when handling ESD-sensitive devices. • Select a grounding system, such as those listed below, to provide protection that meets the specific service requirement. Note: The use of a grounding system is desirable but not required to protect against ESD damage. - Attach the ESD ground clip to any frame - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 15
power cords, telecommunications systems, networks, and modems before you open the device covers, unless instructed otherwise in the installation and configuration same manufacturer. The battery contains lithium and can explode if not properly used, handled, or disposed of. Do not: • Throw or immerse - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 16
on the power supply do not turn off the electrical current supplied to the device. The device also might have more than one power cord. To remove all electrical current from the device, ensure that all power cords are disconnected from the power source. 2 1 8 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 17
Chapter 2. Safety information 9 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 18
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) 2 1 PERIGO 10 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 19
A corrente elétrica proveniente de cabos de alimentação, de telefone e de comunicações é perigosa. Para evitar risco de choque elétrico: • Não conecte nem desconecte nenhum cabo ou execute instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. • Conecte todos os - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 20
cabo de alimentação. Para remover toda a corrente elétrica do dispositivo, assegure que todos os cabos de alimentação estejam desconectados da fonte de alimentação. 2 1 12 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 21
Chapter 2. Safety information 13 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 22
2 1 14 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 23
Chapter 2. Safety information 15 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 24
et de configuration). • Lorsque vous installez, que vous déplacez, ou que vous manipulez le présent produit ou des périphériques qui lui sont raccordés, reportez-vous aux instructions ci-dessous pour connecter et déconnecter les différents cordons. 16 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 25
les unités SOUS TENSION. ATTENTION: Remplacer la pile au lithium usagée par une pile de référence identique exclusivement, (référence 45C1566), ou suivre les instructions du fabricant qui en définit les équivalences. Si votre système est doté d'un module contenant une pile au lithium, vous devez le - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 26
ühren von Oberflächen mit unterschiedlichem elektrischem Potenzial zu vermeiden. • Geräte niemals einschalten, wenn Hinweise auf Feuer, Wasser oder Gebäudeschäden vorliegen. 18 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 27
• Die Verbindung zu den angeschlossenen Netzkabeln, Telekommunikationssystemen, Netzwerken und Modems ist vor dem Öffnen des Gehäuses zu unterbrechen, sofern in den Installations- und Konfigurationsprozeduren keine anders lautenden Anweisungen enthalten sind. • Zum Installieren, Transportieren und Ö - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 28
mit mehreren Netzkabeln ausgestattet sein. Um die Stromversorgung für die Einheit vollständig zu unterbrechen, müssen alle zum Gerät führenden Netzkabel vom Netz getrennt werden. 2 1 20 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 29
Chapter 2. Safety information 21 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 30
a una presa di alimentazione correttamente cablata e dotata di messa a terra. • Collegare alle prese elettriche appropriate tutte le apparecchiature che verranno utilizzate per questo prodotto. 22 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 31
pericolose. All'interno dell'unità non vi sono parti su cui effettuare l'assistenza tecnica. • L'utilizzo di controlli, regolazioni o l'esecuzione di procedure non descritti nel presente manuale possono provocare l'esposizione a radiazioni pericolose. Chapter 2. Safety information 23 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 32
l'unità disponga di più cavi di alimentazione. Per disattivare l'alimentazione dall'unità, accertarsi che tutti i cavi di alimentazione siano scollegati dalla fonte di alimentazione. 2 1 24 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 33
Chapter 2. Safety information 25 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 34
mano para conectar o desconectar los cables de señal. • No encienda nunca un equipo cuando hay señales de fuego, agua o daños estructurales. 26 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 35
• Desconecte los cables de alimentación, los sistemas de telecomunicaciones, las redes y los módems conectados antes de abrir las cubiertas de los dispositivos, a menos que se indique lo contrario en los procedimientos de instalación y configuración. • Conecte y desconecte los cables, como se - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 36
suprimir toda la corriente eléctrica del dispositivo, asegúrese de que todos los cables de alimentación estén desconectados de la toma de corriente. 2 1 28 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 37
: • CRU removal and installation instructions • Publications • Troubleshooting information • Parts information • Downloads and drivers • Links to other useful sources of information To access this information, point your browser to http://www.lenovo.com/support. Specifications This section lists the - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 38
inches) Height: 485 mm (19.1 inches) floor to top of handle Depth: 602 mm (23.7 inches) Weight Maximum configuration: 26.00 kg (57 lbs) Rack mounted dimensions: Width: 427 mm (16.8 inches) Height: 210 mm (8.3 inches) Depth: 602 mm (23.7 inches) Environment 30 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 39
• Humidity: Operating: 10% to 80% (10% per hour) Non-operating: 10% to 90% (10% per hour) Transit: 10% to 90% (10% per hour) • Maximum altitude: 7000 ft (2133.6 m) Electrical input • Input voltage: - Range 100 V - 240 V - Input kilovolt-amperes (kVA) (approximate) Minimum configuration as shipped - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 40
32 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 41
cords. 3. Set all display controls to the middle position. 4. Power-on all external devices. 5. Power-on the computer. • Look for displayed error codes • Listen for beep codes • Look for readable instructions or a main menu on the display. If you did not receive the correct response, proceed to - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 42
version) 7. Have the same configuration options set in the system 8. Have the same setup for the operating system control files Comparing the configuration and software set-up between "working and non-working" systems will often lead to problem resolution. 34 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 43
available on computers preinstalled with Windows 7 from Lenovo. Lenovo Solution Center The Lenovo Solution Center program enables you to troubleshoot and resolve computer problems. It combines diagnostic tests, system information collection, security status, and support information, along with hints - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 44
F1 key for additional help. 6. Follow the instructions on the screen. Note: Rescue media includes PC-Doctor for Windows PE. PC-Doctor for DOS Use PC- the diagnostic program from http://www.lenovo.com/support. After you download the image, you can create the CD/DVD using any CD/DVD burning software. - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 45
you want to run. Press the F1 key for additional help. Navigating through the diagnostics programs Use the cursor movement keys to navigate within the menus. • The Enter key is used to select a menu item. • The Esc key is used to back up to the previous menu. • For online help select F1. Running - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 46
date is retrieved from CMOS and displayed using the YYYYMMDD format. • ChkDigits: Contains a 2-digit check-digit value to ensure the following: - Diagnostics were run on the specified date. - Diagnostics were run on the specified computer. - The diagnostic error code is recorded correctly. • Text - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 47
the user about non-recoverable process. Important: Make sure that all data is backed up before using the instructions. Viewing the test log Errors reported by the diagnostic test will be displayed by the program as a failed test. To view details of a failure or to view a list of test results, use - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 48
40 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 49
settings The Setup Utility program menu lists items that identify system configuration topics. To view or change settings, see "Starting the Setup Utility program " on page 41. When working with the Setup Utility program menu, you must use the keyboard. The keys used to perform various tasks are - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 50
configuration. When disabling this feature, make sure your system has an alternate boot method, such as LAN PXE boot, or a bootable floppy diskette, memory key, or optical disc. When this feature is set to Disabled, the diskette drive cannot be accessed. To set the ICH SATA Controller or Marvell - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 51
to start up from any boot device. Note: Not all discs, hard disk drives, and diskettes are bootable. 1. Turn off your computer. 2. Press and hold the F12 key then turn on the computer. When the Startup Device Menu appears, release the F12 key. Note: If you are using a USB keyboard and the Startup - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 52
Exiting from the Setup Utility program After you finish viewing or changing settings, press Esc to return to the Setup Utility program menu (you might have to press Esc several times). If you want to save the new settings, select Save Settings or Save and exit the Setup - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 53
a hard disk drive" in the ThinkStation Hardware Installation and Replacement Guide. Configuring the system BIOS to enable SATA RAID functionality This section describes how to configure the system BIOS to enable SATA RAID functionality. Note: Use the arrow keys on the keyboard to make selections - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 54
the required number of SAS hard disk drives for the supported level of RAID and SAS RAID configuration. Installing SAS hard disk drives Your computer must have the minimum number of SAS hard disk drives installed for the supported level of RAID below: 46 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 55
ThinkStation Hardware Installation and Replacement Guide. Entering the Marvell BIOS Setup to configure SAS RAID This section describes how to enter the Marvell BIOS Setup to configure SAS RAID. 1. Your computer must have a Marvell SAS adapter card (Marvell SAS controller) installed to configure SAS - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 56
Marvell BIOS Setup to delete an array To configure the Marvell BIOS Setup to delete an array: 1. Turn on your computer and press Ctrl+M when prompted to enter the Marvell BIOS Setup. 2. On the Marvell BIOS Setup screen, use the arrow keys to select RAID Config and press Enter. The RAID Config menu - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 57
how to enter the Marvell BIOS Setup to configure a SATA or SAS RAID. 1. Turn on the computer after you have installed the required number of SATA or SAS hard disk drives. 2. Press Ctrl+M when prompted to enter the Marvell BIOS Setup to configure SATA/SAS RAID. © Copyright Lenovo 2008, 2012 49 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 58
Configuring the Marvell BIOS Setup to enable SATA or SAS RAID 0, 1, 5, or 10 functionality To enable SATA/SAS RAID functionality, use the Marvell BIOS Setup configuration utility as the SATA/SAS configuration utility. This utility assumes that the system has the required number of hard disk drives. - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 59
2. On the Marvell BIOS Setup screen, use the arrow keys to select RAID Config and press Enter. The RAID Config menu opens. 3. From the RAID Config menu, select Delete array. 4. Use the arrow keys and the Enter key to select the array you want to delete from the list. 5. Use the arrow keys to select - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 60
52 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 61
on the boot drive. The drive must be formatted, do the following: 1. Attempt to back-up the data on the failing hard disk drive. 2. Using the operating systems programs, format the hard disk drive. Replace the hard disk drive. Power Supply Problems If you suspect a power problem, use the following - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 62
Refer to the following diagnostic error codes when using the diagnostic tests. See "Running tests" on page 37 for the specific type for information about the Diagnostic programs. In the following index, X can represent any number. Diagnostic Error Code 000-000-XXX BIOS Test Passed 000-002-XXX - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 63
Diagnostic Error Code 000-197-XXX BIOS test warning 000-198-XXX BIOS test aborted 000-199-XXX BIOS test failed, cause unknown 000-250-XXX BIOS APM failure 000-270-XXX BIOS ACPI failure 001-000-XXX System Test Passed 001-00X-XXX System Error 001-01X-XXX System Error 001-024-XXX System Addressing test - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 64
/Action 1. Adapter card 2. System board 1. Flash the system. See "Flash update procedures" on page 251 2. System board 1. Power-off/on system and re-test 2. System board 1. Power-off/on system and re-test 2. System board Information only Re-start the test, if necessary 1. Press F3 to review the log - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 65
RAM error 001-293-XXX System CMOS Battery 001-298-XXX System RTC date/time update update procedures" on page 251 2. System board System board System board 1. Flash the system. See "Flash update procedures" on page 251 2. System board No action 1. Video card, if installed 2. System board 1. Video card - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 66
System BIOS extension failure 005-040-XXX Video IRQ failure 005-195-XXX Video Test aborted by user 005-196-XXX Video test halt, error threshold exceeded 005-197-XXX Video test warning 005-198-XXX Video test aborted 005-199-XXX Video test failed, cause unknown FRU/Action 1. Video Ram 2. Video card - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 67
/Setup error 011-03X-XXX 011-04X-XXX Serial port failure 011-195-XXX Serial port Test aborted by user FRU/Action 1. Video card, if installed 2. System board No action 1. Diskette drive Cable 2. Diskette drive 3. System board Information only Re-start the test, if necessary 1. Press F3 to review the - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 68
Error Code 011-196-XXX Serial port test halt, error threshold update procedures" on page 251 3. System board System board Information only Re-start the test, if necessary 1. Press F3 to review the log file 2. Re-start the test to reset the log file 60 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 69
error 015-040-XXX USB port IRQ failure 015-195-XXX USB port Test aborted by user FRU/Action 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 "Using system and re-test. See "Flash update procedures" on page 251 3. Run memory test 4. System board 1. Remove USB - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 70
3. Go to "Undetermined problems" on page 75 018-199-XXX PCI Card test failed, cause unknown 1. Go to "Undetermined problems" on page 75 2. Flash the system and re-test. See "Flash update procedures" on page 251 3. Replace component under function test 62 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 71
Diagnostic Error Code 018-250-XXX PCI Card Services error 020-000-XXX PCI Interface Test Passed 020-0XX-XXX PCI Interface error 020-195-XXX PCI Test aborted by user 020-196-XXX PCI test halt, error threshold exceeded 020-197-XXX PCI test warning 020-198-XXX PCI test aborted 020-199-XXX PCI test - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 72
update procedures" on page 251 3. SCSI device 4. SCSI adapter card, if installed 5. System board 1. SCSI signal cable 2. Check power supply 3. SCSI device 4. SCSI adapter card, if installed 5. System board Information only Re-start the test, if necessary 64 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 73
aborted by user 035-196-XXX RAID interface test halt, error threshold exceeded 035-197-XXX RAID interface test warning 035-198-XXX RAID interface test aborted 035-199-XXX RAID interface test failed, cause unknown 071-000-XXX Audio port Interface Test Passed FRU/Action 1. Press F3 to review the log - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 74
-XXX Game Port interface Error 080-195-XXX Game Port interface Test aborted by user 080-196-XXX Game Port interface test halt, error threshold exceeded FRU/Action 1. Run Setup 2. Flash the system. See "Flash update procedures" on page 251 3. System board 1. Speakers 2. Microphone 3. Audio card, if - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 75
Diagnostic Error Code 080-197-XXX Game Port interface test warning 080-198-XXX Game Port interface test aborted 080-199-XXX Game Port interface test failed, cause unknown 086-000-XXX Mouse Port interface Test Passed 086-001-XXX Mouse Port interface Presence 086-032-XXX Mouse - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 76
under test 1. If a component is called out, make sure it is connected and/or enabled. See Chapter 6 "Using the Setup Utility" on page 41 2. Flash the system and re-test. See "Flash update procedures" on page 251 3. Go to "Undetermined problems" on page 75 68 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 77
Security Chassis Intrusion 201-000-XXX System Memory Test Passed FRU/Action 1. See "Undetermined problems" on page 75 2. Flash the system and re-test. See "Flash update procedures" on page 251 3. Replace component under function test 1. Power supply 2. System board 1. Voltage Regulator Module (VRM - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 78
error FRU/Action 1. Replace the memory module called out by the test 2. System board No action 1. Cache, if removable 2. System board 3. Microprocessor No action 1. Diskette Drive Cable 2. Check power supply Remove the Joystick and re-test the system 70 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 79
beeps Monitor or video adapter card error 1 long and 3 short beeps Keyboard error 1 long and 9 short beeps BIOS ROM error Continuos long beeps DRAM memory error FRU/Action Perform the following actions in order. 1. Start the Setup Utility program and press F10 to Save and exit. See Chapter 6 "Using - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 80
of tests is called the Power-On Self-Test, or POST. POST does the following operations. • Checks some basic system-board operations • Checks the memory operation • Starts the video operation • Verifies that the boot drive is working If the POST detects a problem, an error message appears on the - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 81
conflicts 6. Network adapter (advise network administrator of new MAC address) Dead computer. See "Hard disk drive boot error" on page 53. 1. Power Supply 2. System Board Diskette drive in-use light remains on or does not light when drive is active. 1. Diskette Drive 2. System Board 3. Diskette - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 82
from left to right of characters and color bars 1. Display 2. Video adapter (if present) 3. System Board No power or fan not running 1. See "Hard disk drive boot error" on page 53. Non-system disk or disk error-type message with a known-good diagnostic diskette. 1. Diskette Drive 2. System - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 83
d. Extended video memory e. External Cache f. External Cache RAM g. Hard disk drive h. Diskette drive 3. Power-on the computer to re-test the system. 4. Repeat steps 1 through 3 until you find the failing device or adapter. If all devices and adapters have been removed, and the problem continues - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 84
76 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 85
some 7 Hard disk drive activity light models) 3 USB connector 8 Power button 4 Microphone connector 9 Power-on indicator 5 Headphone connector Rear connectors The following illustration shows the locations of the connectors on the rear of the computer. © Copyright Lenovo 2008, 2012 77 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 86
Power cord connector 9 2 Serial port 10 3 Ethernet connector 11 4 Serial port (some models) 12 5 Audio line-out subwoofer/center speakers 13 connector 6 Audio line-in connector 14 7 Video Open the keylock if it is in the locked position. 78 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 87
5. Disengage the cover latch 1 and remove the cover. Place the cover on a flat surface. Locations The following illustration will help you locate the major FRUs in the computer. Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 79 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 88
1 Microprocessor, heat sink, and heat sink fan 5 Hard disk drives assembly 2 Optical drive 6 Rear fan assembly 3 3.5-inch diskette drive or card reader 7 Power supply 4 Internal speaker 80 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 89
slot 9 Front USB connector 24 PCI Express x16 graphics adapter card slot 10 SATA connectors (5) 25 PCI Express x4 adapter card slot 11 Adapter card fan connector 26 PCI Express x16 graphics adapter card slot 12 SAS (Serial Attached SCSI) LED connector 27 Second COM port connector 13 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 90
bezel with the corresponding holes in the chassis, then pivot the bezel inward until it snaps into position on the left side. Replacing the power supply Attention Never remove the cover on a power supply or any part that has the following label attached. 82 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 91
that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides information on how to remove or replace the power supply. To replace the power supply, do the following: 1. Remove the computer cover and then lay - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 92
the screw holes in the power supply align with those in the chassis. Note: Use only the screws provided by Lenovo. 9. Install and tighten the five screws at the rear of the chassis to secure the power supply. Reconnect all power supply cables to the drives, adapter cards, and the system board. Make - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 93
cover. This section provides instructions on how to replace a memory module. Your computer has 6 slots for installing or replacing DDR3 UDIMMs (double data rate 3 error correction code unbuffered dual inline memory modules). When installing or replacing memory modules, use the following guidelines - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 94
with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides information on how to remove or replace a PCI adapter card. To remove or replace the PCI adapter card, do the following: 1. Remove the computer cover. See - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 95
6. Release the adapter card support retaining latch 1 if necessary. Grasp the failing adapter card and pull the adapter card out of the slot. Note: The adapter card fits tightly into the card slot. If necessary, alternate moving each side of the adapter card a small amount until it is removed from - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 96
7. Remove the new adapter card from its static-protective package. 8. Install the new adapter card into the appropriate adapter card slot on the system board. See "Locating parts on the system board " on page 81. 88 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 97
Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 89 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 98
cables to the system board. 10. Latch the adapter card retainer. 11. Go to "Completing the FRU ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 99
not have orientation labels should be oriented so the fan cable is toward the board connector labeled "CPU Fan." 7. Place the new heat sink into position. Partially tighten screw 3 , then fully tighten screw 4 , and fully tighten screw 3 . Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 91 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 100
10. Reconnect the heat sink fan cable. See "Locating ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions 92 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 101
. 7. Lower the microprocessor straight down into the microprocessor socket of the system board. 8. Close the microprocessor retainer and clamp it with the small handle. Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 93 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 102
the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. Note: When replacing the system board a new retention module for the microprocessor heat sink is required. Make sure you have a new retention module before beginning this procedure. This section provides instructions - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 103
Carefully lift the system board out of the chassis. 10. Remove the microprocessor socket cover from the new socket. c. Align the notches 1 of the microprocessor socket cover with the alignment keys 2 of the microprocessor socket. Lower the socket cover straight down into the microprocessor socket - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 104
instructions memory fan assembly" on page 100. 19. Connect all cables to the system board. See the system board illustration for your machine type at "Locating parts on the system board " on page 81. 20. Go to "Completing the FRU replacement" on page 108. 96 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 105
understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace a hard disk drive - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 106
connect one end of the signal cable to the drive. Locate one of the extra five-wire power cables and connect it to the drive. Note: The signal cable will be different depending on whether you are installing a SATA hard disk drive or a SAS hard disk drive. 98 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 107
Figure 3. Connecting a 3.5-inch SATA hard disk drive Figure 4. Connecting a 2.5-inch SATA hard disk drive Figure 5. Connecting a 3.5-inch SAS hard disk drive 9. Go to "Completing the FRU replacement" on page 108. Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 99 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 108
that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. Your computer might have a hard disk drive fan assembly installed. To replace the hard disk drive fan assembly: 1. Remove the computer cover. See "Removing the cover - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 109
ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions optical drive cables. Disconnect the signal and power cables from the rear of the optical drive - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 110
safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the diskette drive or card reader. To remove or - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 111
5. Press the drive latch 1 and slide the drive out the front of the computer. 6. Slide the new diskette drive or card reader into the drive bay until it snaps into position. Chapter 10. Replacing FRUs (Type 4105, 4157, 4217) 103 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 112
with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the front or rear fan assembly. To remove or replace the front or rear fan assembly, do the following: 1. Remove the computer - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 113
and understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the front panel - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 114
To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. Your computer has a special type of memory that maintains the date, time, and settings for built-in features, such as serial-port assignments (configuration). A battery keeps this information active - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 115
understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the internal speaker - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 116
updated information in the Setup Utility program. Note: When the power update (flash) the BIOS. See "Flash update procedures" on page 251. 5. Some FRU replacements require the configuration to be updated. See Chapter 6 "Using the Setup Utility" on page 41. 108 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 117
4158, 4218) Important Before you replace any FRU, read Chapter 2 "Safety information" on page 3. These precautions and guidelines will help you work safely. FRU replacements are to be done by trained service locations of the connectors on the rear of the computer. © Copyright Lenovo 2008, 2012 109 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 118
computer cover: 1. Remove any media from the drives and shut down your operating system. Turn off all attached devices. Turn off the computer. 2. Unplug all power cords from electrical outlets. 110 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 119
3. Disconnect the cables attached to the computer. This includes power cords, input/output (I/O) cables, and any other cables that are connected to the computer. See "Locating illustration will help you locate the major FRUs in the computer. Chapter 11. Replacing FRUs (Type 4155, 4158, 4218) 111 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 120
sinks (2) 2 Optical drive bays (3) 3 Internal speaker 4 3.5-inch diskette drive or card reader 5 Front bezel 6 Hard disk drive bays (5) 7 Hard disk drive fan assembly 8 Adapter card retainer 9 Rear fan assembly 10 Power supply assembly 112 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 121
heat sink 2 7 CPU 2 12 V power connector 8 24-pin power connector 9 CPU 2 fan connector 10 CPU 2 memory fan connector 11 CPU 2 memory slots (6) 12 Power switch/LEDs connector 13 Auxiliary LED connector 14 Hard disk drive fan connector 15 Diskette drive connector 16 Card reader - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 122
Never remove the cover on a power supply or any part that has the following label attached. Hazardous voltage, current, and energy levels are present inside any component that has this label attached. There are no servicable parts inside these components. 114 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 123
that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides information about how to move and replace the power supply. To replace the power supply, do the following: 1. Remove the computer cover and then - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 124
: Use only the screws provided by Lenovo. 9. Install and tighten the four screws at the rear of the chassis to secure the power supply. 10. Install and tighten the two screws that secure the power supply to the inside of the chassis. 11. Reconnect all power supply cables to the drives, adapter cards - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 125
. 6. Position the new memory module over the memory slot. Make sure the notch 1 on the memory module aligns correctly with the slot key 2 on the system board. Push the memory module straight down into the slot until the retaining clips close. Chapter 11. Replacing FRUs (Type 4155, 4158, 4218) 117 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 126
memory fan cable to the system board. 8. Go to "Completing the FRU replacement" on page 108. Note: Your system memory ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides information about how to replace a PCI adapter card. To replace a PCI adapter card - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 127
additional retention feature located on the card guide end. Push the retention feature toward the front of the chassis before removing the adapter card. 6. Release the card support retaining latches. Grasp the adapter card and pull the card out of the slot. Note: The card is a tight fit, so it might - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 128
120 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 129
Reverse this procedure to install the card. 8. Go to "Completing the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions (Type 4155, 4158, 4218) 121 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 130
fan cable is toward the board connector labeled "CPU Fan . 10. Reconnect the heat sink fan cable ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 131
when installing it into the socket. 7. Lower the microprocessor straight down into the microprocessor socket of the system board. Chapter 11. Replacing FRUs (Type 4155, 4158, 4218) 123 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 132
the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. Note: When replacing the system board a new retention module for the microprocessor heat sink is required. Make sure you have a new retention module before beginning this procedure. This section provides instructions - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 133
lift the system board out of the chassis. 10. Remove the microprocessor socket cover from the new microprocessor socket. c. Align the notches 1 of the microprocessor socket cover with the alignment keys 2 of the microprocessor socket. Lower the socket cover straight down into the microprocessor - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 134
instructions memory fan assembly" on page 100. 19. Connect all cables to the system board. See the system board illustration for your machine type at "Locating parts on the system board " on page 113. 20. Go to "Completing the FRU replacement" on page 108. 126 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 135
understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the hard disk drive - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 136
connect one end of the signal cable to the drive. Locate one of the extra five-wire power cables and connect it to the drive. Note: The signal cable will be different depending on whether you are installing a SATA hard disk drive or a SAS hard disk drive. 128 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 137
Figure 8. Connecting a 3.5-inch SATA hard disk drive Figure 9. Connecting a 2.5-inch SATA hard disk drive Figure 10. Connecting a 3.5-inch SAS hard disk drive 9. Go to "Completing the FRU replacement" on page 108. Chapter 11. Replacing FRUs (Type 4155, 4158, 4218) 129 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 138
with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the hard disk drive fan assembly. To replace the hard disk drive fan assembly: 1. Remove the computer cover. See "Removing - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 139
ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions optical drive cables. Disconnect the signal and power cables from the rear of the optical drive - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 140
that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the diskette drive or card reader. 1. Remove the computer cover. See "Removing the cover" on page 78. 2. Remove - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 141
card reader and connect it to the new drive. 9. Slide the new diskette drive or card reader into the drive bay until it snaps into position. 10 ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the front and rear fan - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 142
and understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the front panel - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 143
that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This procedure describes how to remove and replace the power switch/LED assembly. 1. Remove the computer cover. See "Removing the cover" on page 110. 2. Remove the - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 144
To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. Your computer has a special type of memory that maintains the date, time, and settings for built-in features, such as serial-port assignments (configuration). A battery keeps this information active - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 145
understanding the "Important safety information" in the ThinkStation Safety and Warranty Guide that came with your computer. To obtain a copy of the ThinkStation Safety and Warranty Guide, go to: http://www.lenovo.com/support. This section provides instructions on how to replace the internal speaker - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 146
" on page 109. 4. If you have replaced the system board, you must update (flash) the BIOS. See "Flash update procedures" on page 251. 5. Some FRU replacements require the configuration to be updated. See Chapter 6 "Using the Setup Utility" on page 41. 138 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 147
as either "1", "2", or "N" in the CRU column. "N" means that the part is not a CRU, "1" means that the part is a Self-service CRU, and "2" means that the part is an Optional-service CRU. Overall: MT 4105, 4157 and 4217 The following replaceable components are available for the 4105, 4157 and 4217 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 148
• MT 4105: all models • MT 4157: all models • MT 4217: all models Heat sink, Bloomfield workstation • MT 4105: all models • MT 4157: all models • MT 4217: all models Microprocessor, Intel Xeon 71Y9027 46R6406 46R6407 64Y9827 64Y9829 CRU 2 2 N N N N N N 140 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 149
Item # 2 2 2 2 2 2 2 2 FRUs Microprocessor, Intel Xeon E5502 - 1.86GHz, Dual Core 4.8 QPI, 4MB L2, DDR3-800, 80W • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Microprocessor, Intel Xeon E5503 - Dual Core - 2.00GHz - 4.8 QPI DDR3-800-4MB 80W • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Microprocessor - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 150
-1333, Turbo, SMT, 95W • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Microprocessor, Intel Xeon X5650 - 6 Core - 2.66GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 95W • MT 4105: CTO E9G F5G • MT 46R6638 46R6639 71Y9043 71Y9041 71Y9039 46R6640 CRU N N N N N N N N 142 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 151
Item # 2 2 2 2 2 2 2 2 FRUs Microprocessor, Intel Xeon X5680 - 6 Cores - 3.33GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 130W • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Microprocessor, Intel Xeon X5677 - Quad Core - 3.46GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 130W • MT 4105: CTO • MT 4157: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 152
, DDR3 - 1333, Turbo, HT, 95W • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU # 71Y8842 03T8032 03T8031 03T8030 03T8029 03T8027 03T8028 03T8026 CRU N N N N N N N N 144 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 153
Item # 2 2 2 2 2 2 2 FRUs Microprocessor, Intel Xeon X5675 - 6 Core - 3.06Ghz - 6.4 QPI, 12MB Cache, DDR3 - 1333, Turbo, HT, 95W • MT 4105: CTO 2RH • MT 4157: CTO • MT 4217: CTO Microprocessor, Intel Xeon X5687 - Quad Core - 3.6Ghz - 6.4 QPI, 12MB Cache, DDR3 - 1333, Turbo, HT, 130W • MT 4105: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 154
1GB 2AG 2BG 2CG 2DG • MT 4157: CTO 1AG 2AG 3AG 4AG 5AG 6AG 2CG • MT 4217: CTO FRU # 71Y8819 71Y8823 71Y8820 71Y8824 CRU N N N N 146 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 155
1CU 1CF 2CU 2CF 2CS 2CP 2CL 2CD 2CY 2CG 2CM 2CA 2CQ 2CT 2CC 2CB 2CH 2CV 2CK 2CR 2CE 2CJ • MT 4217: CTO Memory module, 1GB DDR3 ECC UDIMM PC3-10600 (1333MHz) • MT 4105: CTO • MT 4157: CTO B5A B5Q B5T B5K B5R • MT 4217: CTO FRU # 46R4544 64Y6337 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 156
Memory module, 4GB Memory module, 8GB DDR3 ECC UDIMM (9-9-9) PC3-10600 (1333MHz) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Optical drive, DVD-ROM drive - 16x/48x (SATA) - DOS/Linux • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Optical drive, DVD-ROM drive - 16x/48x (SATA) - DOS/Linux - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 157
5CG • MT 4217: CTO Optical drive, DVD burner/CD-RW Rambo 8 (SATA) - DOS/Linux • MT 4105: CTO 96G D2G M2G N5M N7M L4H E6G E9G F1G F4G Mode FDD-SONY • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU, power switch, LED cable and power button kit • MT 4105: all models • MT 4157: all models • MT 4217: all - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 158
MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Hard disk drive, 147GB SAS - 15000 rpm, 3 Gb/s, 32MB cache, 3.5" • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU # 46R6029 46R6030 43C3671 46R6031 46R6032 46R6400 46R6401 46R6033 45K0608 CRU 1 1 1 1 2 2 2 1 1 150 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 159
M6G M8M N4U N4F N5U N5F N6U N6F 2BJ 5BJ 6BJ • MT 4217: CTO Hard disk drive, 300GB SAS - 15000 rpm, 3 Gb/s, 32MB cache, 3.5" • MT 4105: CTO 1CG 2DG • MT 4157: 2CK 2CR 2CE 2CJ • MT 4217: CTO Hard disk drive, 128GB SATA solid state drive (SSD) - MLC, 1.8" • MT 4105: CTO • MT 4157: CTO M6G • - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 160
, 2.5" • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Hard disk drive, 600GB SAS - 15000 rpm, 3.5" • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU # 45N7963 45N8019 45K0610 45K0412 45K0617 45K0618 03T7026 45K0616 91Y1658 03X3616 CRU 1 1 1 1 1 1 1 1 1 1 152 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 161
4157: CTO 3DG 5CG • MT 4217: CTO Hard disk drive, 1TB SATA - 7200 rpm, 3.5" • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Rear fan, exhaust fan assembly • MT 4105: all models • MT 4157: all models • MT 4217: all models Power supply, 625 Watt power supply • MT 4105: CTO 96G D2G M2G N5M N7M L4H E6G E9G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 162
FRUs FRU, PS2 keyboard/mouse card and cable assembly • MT 4105: all models • MT 4157: all models • 4217: all models FRU, cable assembly, SAS hard disk drive • MT 4105: all models • MT 4157: all models • MT 4217: all models 154 ThinkStation Hardware Maintenance Manual FRU # 41R5604 CRU 2 41R5625 2 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 163
models • MT 4217: all models FRU, cable assembly, SATA optical drive • MT 4105: all models • MT 4157: : all models • MT 4217: all models FRU, PS/2 card and bracket assembly • MT 4105: all models • MT 4157 4157: all models • MT 4217: all models FRU, SAS hard disk drive filler • MT 4105: all models • - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 164
kit • MT 4105: all models • MT 4157: all models • MT 4217: all models FRU, hard disk drive SATA cable - Camus • MT 4105: all models • MT 4157: all models • MT 4217: all models FRU, second 4217: CTO FRU # 41A5289 41A5290 41A5291 CRU 2 2 2 2 2 CRU 1 1 1 156 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 165
Keyboard - USB Preferred Pro Full size Belgian/French • MT 4105: CTO 96G D2G M2G E6G E9G F1G F4G F5G J6G J7G K7G P1G P2G O4G O5G O6G O7G 1CG 2AG 2BG 2CG 2DG 3CG 4CG 8CG 9CG 4AG • MT 4157: CTO B4G F3G F4G F6G G6G G8G M6G 1AG 2AG 3AG 4AG 5AG 6AG 2CG 3CG 3DG 5CG • MT 4217: CTO Belgian/UK • MT 4105: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 166
M6G 1AG 2AG 3AG 4AG 5AG 6AG 2CG 3CG 3DG 5CG • MT 4217: CTO FRU # 41A5300 41A5301 41A5302 41A5303 41A5304 41A5305 41A5306 41A5307 CRU 1 1 1 1 1 1 1 1 158 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 167
Keyboard - USB Preferred Pro Full size Iceland • MT 4105: CTO 96G D2G M2G E6G E9G F1G F4G F5G J6G J7G K7G P1G P2G O4G O5G O6G O7G 1CG 2AG 2BG 2CG 2DG 3CG 4CG 8CG 9CG 4AG • MT 4157: CTO B4G F3G F4G F6G G6G G8G M6G 1AG 2AG 3AG 4AG 5AG 6AG 2CG 3CG 3DG 5CG • MT 4217: CTO Italy • MT 4105: CTO 96G D2G M2G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 168
G8G M6G 1AG 2AG 3AG 4AG 5AG 6AG 2CG 3CG 3DG 5CG • MT 4217: CTO FRU # 41A5317 41A5316 41A5318 41A5319 41A5320 41A5321 41A5322 CRU 1 1 1 1 1 1 1 160 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 169
Keyboard - USB Preferred Pro Full size Swiss French/German • MT 4105: CTO 96G D2G M2G E6G E9G F1G F4G F5G J6G J7G K7G P1G P2G O4G O5G O6G O7G 1CG 2AG 2BG 2CG 2DG 3CG 4CG 8CG 9CG 4AG • MT 4157: CTO B4G F3G F4G F6G G6G G8G M6G 1AG 2AG 3AG 4AG 5AG 6AG 2CG 3CG 3DG 5CG • MT 4217: CTO Thailand • MT 4105: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 170
4157: • MT 4217: Czech • MT 4105: • MT 4157: • MT 4217: Danish • MT 4105: • MT 4157: • MT 4217: Keyboard - Full Size PS/2 162 ThinkStation Hardware Maintenance Manual FRU # 41A5039 CRU 1 41A5040 1 41A5041 1 41A5042 1 41A5043 1 41A5044 1 41A5045 1 41A5046 1 41A5047 1 41A5048 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 171
Dutch • MT 4105: • MT 4157: • MT 4217: French • MT 4105: • MT 4157: • MT 4217: French Canadian • MT 4105: • MT 4157: • MT 4217: French Canadian • MT 4105: • MT 4157: • MT 4217: German • MT 4105: • MT 4157: • MT 4217: Greek • MT 4105: • MT 4157: • MT 4217: Greek/US • MT 4105: • MT 4157: • MT 4217: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 172
/Cyrillic • MT 4105: • MT 4157: • MT 4217: Serbian/Cyrillic • MT 4105: • MT 4157: • MT 4217: Keyboard - Full Size PS/2 164 ThinkStation Hardware Maintenance Manual FRU # 41A5058 CRU 1 41A5059 1 41A5060 1 41A5061 1 41A5062 1 41A5063 1 41A5064 1 41A5065 1 41A5066 1 41A5067 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 173
Slovak • MT 4105: • MT 4157: • MT 4217: Spanish • MT 4105: • MT 4157: • MT 4217: Swedish/Finnish • MT 4105: • MT 4157: • MT 4217: Swiss French/German • MT 4105: • MT 4157: • MT 4217: Thailand • MT 4105: • MT 4157: • MT 4217: Turkish • MT 4105: • MT 4157: • MT 4217: Turkish • MT 4105: • MT 4157: • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 174
: • MT 4217: Czech • MT 4105: • MT 4157: • MT 4217: Danish • MT 4105: • MT 4157: • MT 4217: Keyboard - Enhanced Performance 166 ThinkStation Hardware Maintenance Manual FRU # 41A4961 CRU 1 41A4962 1 41A4963 1 41A4964 1 41A4965 1 41A4966 1 41A4967 1 41A4968 1 41A4969 1 41A4970 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 175
Dutch • MT 4105: • MT 4157: • MT 4217: French • MT 4105: • MT 4157: • MT 4217: French Canadian • MT 4105: • MT 4157: • MT 4217: French Canadian • MT 4105: • MT 4157: • MT 4217: German • MT 4105: • MT 4157: • MT 4217: Greek • MT 4105: • MT 4157: • MT 4217: Greek/US • MT 4105: • MT 4157: • MT 4217: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 176
Cyrillic • MT 4105: • MT 4157: • MT 4217: Serbian/Cyrillic • MT 4105: • MT 4157: • MT 4217: Keyboard - Enhanced Performance 168 ThinkStation Hardware Maintenance Manual FRU # 41A4980 CRU 1 41A4981 1 41A4982 1 41A4983 1 41A4984 1 41A4985 1 41A4986 1 41A4987 1 41A4988 1 41A4989 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 177
Keyboard - Enhanced Performance Slovak • MT 4105: • MT 4157: • MT 4217: Spanish • MT 4105: • MT 4157: • MT 4217: Swedish/Finnish • MT 4105: • MT 4157: • MT 4217: Swiss French/German • MT 4105: • MT 4157: • MT 4217: Thailand • MT 4105: • MT 4157: • MT 4217: Turkish • MT 4105: • MT 4157: • MT 4217: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 178
• MT 4217: CTO Czech (ABB) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Danish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO 170 ThinkStation Hardware Maintenance Manual FRU # 41R0038 CRU 1 41R0039 1 41R0040 1 41R0041 1 41R0042 1 41R0043 1 41R0044 1 41R0045 1 41R0046 1 41R0047 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 179
Keyboard - USB Preferred Pro Fingerprint Keyboard Dutch • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO French • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO French Canadian • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO French Canadian • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO German • MT 4105: CTO • - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 180
4217: CTO Romanian • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Russian/Cyrillic • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO 172 ThinkStation Hardware Maintenance Manual FRU # 41R0058 CRU 1 41R0059 1 41R0060 1 41R0061 1 41R0062 1 41R0063 1 41R0064 1 41R0065 1 41R0066 1 41R0067 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 181
Keyboard - USB Preferred Pro Fingerprint Keyboard Serbian/Cyrillic • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Slovak • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Spanish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Swedish/Finnish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Swiss French/German • - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 182
3CG 4CG 5CU 5CF 6CU 6CF 7CM 8CG 9CG 4AG 4BH • MT 4157: CTO • MT 4217: CTO FRU # 41U3013 41U3030 41U3078 45J4889 CRU 1 1 CRU 1 1 1 1 174 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 183
Logo (Secondary) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Lenovo 3 pieces speakers (China only) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Lenovo 2 pieces speakers (China only) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Speaker power brick • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO 256MB - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 184
: CTO • MT 4217: CTO 1.5GB NVIDIA FX4800 (DVI + DP + DP + ST), 2x3 power connector . • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO 256MB NVIDIA NVS295 : CTO • MT 4157: CTO • MT 4217: CTO 176 ThinkStation Hardware Maintenance Manual FRU # 46R2788 CRU 1 46R2792 1 46R2782 1 89Y0429 1 46R2794 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 185
(computer adapter) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO SAS controller card - 3Gb/s, 4-port host bus adapter • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO SoundBlaster Titanium audio card (PCIe) • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Modem phone cable • MT 4105: CTO • MT 4157: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 186
CTO • MT 4157: CTO • MT 4217: CTO FRU # 89Y8628 89Y8629 89Y8630 03T8009 03T8152 03T8039 03T8040 03T8418 Power Cords Power Cords Line Cord - US • MT 4105: CTO F8A F8T R9U R9F O1U O1F O3U O3F 1KU 1KF 2CD 2CA 2CT FRU # 41R3184 178 ThinkStation Hardware Maintenance Manual CRU 1 1 1 1 1 1 1 1 CRU 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 187
Power Cords • MT 4217: CTO Line Cord - China • MT 4105: CTO K7C 1FC • MT 4157: CTO 2CC • MT 4217: CTO Line Cord - Japan and Japanese English • - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 188
Power Cords Line Cord - A models • MT 4105: CTO M9M N7M 1AG 2AG 3AG 4AG 5AG 6AG 2CG 2CM 2CA 3CG 3DG 5CG Line Cord - India • MT 4105: CTO F8Q • MT 4157: CTO B5Q 2CQ • MT 4217: CTO Line 41R3228 41R3236 41R3220 41R3341 43N9057 45J9502 CRU 1 1 1 1 1 1 1 1 180 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 189
Power Cords - Secondary Line Cord - US • MT 4105: CTO F8A F8T R9U R9F O1U O1F O3U O3F 1KU 1KF 2EU 2EF 2FU 2FF 3AU 3AF 5CU - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 190
Windows XP Professional 64 Mono Recovery CD Note: The Windows XP Professional recovery DVDs are available only for models with a valid Microsoft Windows XP Professional certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing 182 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 191
COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system specified on the COA. Windows XP Professional 64 Mono Recovery CD US English • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Japanese • MT 4105: CTO • MT 4157: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 192
Finnish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Polish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Vista Bussiness 32 184 ThinkStation Hardware Maintenance Manual FRU # 64Y3676 CRU 1 64Y3677 1 64Y5662 1 64Y3699 1 64Y3700 1 64Y3697 1 64Y3691 1 64Y3678 1 64Y3698 1 64Y3679 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 193
Vista Bussiness 32 Russian • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Turkish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Hungarian • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Greek • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Simplified Chinese • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 194
a valid Microsoft Windows Vista certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing limitation, if a model came with Windows Vista Business or Windows Vista Ultimate preinstalled from the factory, but has a Windows 7 186 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 195
COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system specified on the COA. Windows Vista Business 64 Recovery CD English • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Russian English • MT 4105: CTO • MT 4157: CTO • MT 4217: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 196
Windows Vista Business 64 Recovery CD Swedish • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Greek • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO 188 ThinkStation Hardware Maintenance Manual FRU # 64Y3797 CRU 1 64Y3794 1 64Y3790 1 64Y3777 1 64Y3795 1 64Y3778 1 64Y3779 1 64Y3780 1 64Y3781 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 197
Windows Vista Business 64 Recovery CD Simplified Chinese • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO Traditional Chinese • MT 4105: CTO • MT 4157: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 198
• MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU # 64Y3799 64Y3800 Windows 7 Professional 64 SP1 Recovery CD Windows 7 Professional 64 SP1 Recovery CD US English • MT 4105: CTO M2G N5M N7M L4H F8A 03W2908 03W2890 03W2892 03W2888 CRU 1 1 CRU 1 1 1 1 190 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 199
Windows 7 Professional 64 SP1 Recovery CD Polish • MT 4105: CTO 96G D2G M2G J6G J7G K7G P1G P2G O4G O5G O6G O7G 2AG 2BG 2CG 2DG - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 200
Windows 7 Professional 64 SP1 Recovery Traditional Chinese • MT 4105: CTO F8V 1GB • MT 4157: CTO C3B C3H 2CB 2CV • MT 4217: CTO India English • MT 4105: CTO • MT 4157: CTO 2CQ • MT 4217: CTO Hong Kong • MT 4105: 03W2895 03W2902 03W2905 CRU 1 1 1 1 1 1 1 1 192 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 201
Windows 7 Professional 64 SP1 Recovery CD C&L Bel Lux (EN FR GR NL) • MT 4105: CTO 96G D2G M2G J6G J7G K7G P1G P2G O4G O5G O6G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 202
Recovery CD Windows 7 Ultimate 64 SP1 Recovery CD US English • MT 4105: CTO • MT 4157: CTO • MT 4217: CTO FRU # 03W2883 CRU 1 1 CRU 1 Overall: MT 4155, 4158, and 4218 The following replaceable components are available for the 4155, 4158, and 4218 machine type models. 194 ThinkStation Hardware - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 203
Item# 1 2 FRUs Power supply, 1060 Watt power supply • MT 4155: CTO D1G D4G E7M E1U E1F D7C A4H A4V 93G N5U N5F N6M N7M N8M N9G O1G O2G O3G O4G O5G O6G • MT 4218: Fan, memory cooling • MT 4155: all models • MT 4158: all models • MT 4218: all models FRU # 41A9761 45J9607 CRU 2 2 Chapter 12. FRU lists - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 204
RDIMM PC3-8500 (1066MHz) • MT 4155: CTO • MT 4158: CTO • MT 4218: Memory module, 2GB DDR3 2RX8 RDIMM PC3-8500 (1066MHz) • MT 4155: CTO A4H A4V • MT 4158: CTO • MT 4218: FRU # 41R5578 41R5580 46R6026 46R6027 64Y9570 46R6022 46R6023 CRU 2 2 1 1 1 1 1 196 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 205
PC3-8500 (1066MHz) • MT 4155: CTO • MT 4158: CTO • MT 4218: Memory module, 8GB DDR3 4RX4 RDIMM PC3-8500 (1066MHz) • MT 4155: CTO • MT 4158: CTO • MT 4218: Memory module, 1GB DDR3 ECC UDIMM PC3-8500 (1066MHz) • MT 4155: CTO • MT 4158: CTO • MT 4218: Memory module, 2GB DDR3 ECC UDIMM PC3-8500 (1066MHz - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 206
5 FRUs Memory module, 8GB DDR3 ECC UDIMM (9-9-9) PC3-10600 (1333MHz) • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Optical drive, DVD-ROM drive - 16x/48x (SATA) - DOS/Linux • MT 4155: CTO • MT 4158: CTO M6J • MT 4218: Optical drive, DVD-ROM drive - 16x/48x (SATA) - DOS/Linux • MT 4155: CTO • MT 4158 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 207
N3E N3J N5U N5F N6M N7M N8M N9G O1G O2G O3G O4G O5G O6G • MT 4218: Hard disk drive, 750GB SATA - 7200 rpm, 3 Gb/s, 16MB cache, 3.5" • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Hard disk drive, 1TB SATA - 7200 rpm, 3 Gb/s, 32MB cache, 3.5" • MT 4155: CTO H2M J9H K2G K3G • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 208
FRUs Hard disk drive, 300GB SATA - 10000 rpm, 3 Gb/s, 16MB cache, 2.5" • MT 4155: CTO • MT 4158: CTO J1G J3U J3F J4U J4F • MT 4218: CTO Hard disk drive, 147GB SAS - 15000 rpm, 3 Gb/s, 32MB cache, 3.5" • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Hard disk drive, 147GB SAS - 15000 rpm, 3 Gb/s, 32MB - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 209
CTO • MT 4218: CTO Hard disk drive, 256GB SATA Solid State Drive (SSD) - MLC, 1.8" • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Hard disk drive, 160GB SATA Solid State Drive (SSD) - MLC, 1.8" • MT 4155: CTO • MT 4158: CTO Hard disk drive, 160GB SATA Solid State Drive (SSD) - MLC, 1.8" • MT 4155: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 210
Item# 8 8 8 8 8 8 9 10 10 FRUs Hard disk drive, 600GB SATA - 10000 rpm, 16MB cache, 2.5" • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Hard disk drive, 600GB SAS - 15000 rpm, 3.5" • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Hard disk drive, 600GB SAS - 15000 rpm, 3.5" • MT 4155: CTO • MT 4158: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 211
10 10 10 10 10 10 10 10 FRUs Microprocessor, Intel Xeon E5504 - 2.00GHz, Quad Core- 4.8QPI, 4MB L2, DDR3-800, 80W • MT 4155: CTO • MT 4158: CTO • MT 4218: Microprocessor, Intel Xeon E5506 - 2.13GHz, Quad Core - 4.8QPI, 4MB L2, DDR3-800, 80W • MT 4155: CTO • MT 4158 K3G K7G • MT 4158: CTO D6U D6F D6S - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 212
• MT 4158: CTO • MT 4218: Microprocessor, Intel Xeon X5680 - 6 Cores - 3.33GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 130W • MT 4155: CTO • MT 4158: CTO • MT 4218: FRU # 71Y9045 46R6638 46R6639 71Y9043 71Y9041 71Y9039 46R6640 71Y9033 CRU N N N N N N N N 204 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 213
Item# 10 10 10 10 10 10 10 10 FRUs Microprocessor, Intel Xeon X5677 - Quad Core - 3.46GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 130W • MT 4155: CTO • MT 4158: CTO • MT 4218: Microprocessor, Intel Xeon X5670 - 6 Core - 2.93GHz - 6.4 QPI DDR3-1333-12MB Turbo SMT 95W • MT 4155: • MT 4158: CTO • MT 4218: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 214
M8J O3G • MT 4218: CTO Microprocessor, Intel Xeon L5630 - Quad Core - 2.13GHz - 5.86 QPI, 12MB Cache, DDR3-1066, Turbo, HT, 40W • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO FRU # 03T8027 03T8028 03T8026 03T8025 03T8024 03T8023 03T8045 CRU N N N N N N N 206 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 215
• MT 4155: D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: D6G C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G ) • MT 4155: D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: D6G C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G N3G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 216
USB resistors + Marvell 3.1.0.21 FW) • MT 4155: J1J J2J J3J J4J J5J J6J J7J J8J J9H K1G K2G K3G K4U K4F K6G K7G • MT 4158: CTO D6U Ibiza - 2P Intel LGA 1366, Tylersburg 36D, ICH10 (capacitor update for shutdown issue) • MT 4155: J1J J2J J3J J4J J5J J6J J7J N 208 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 217
4155: J1J J2J J3J J4J J5J J6J J7J J8J J9H K1G K2G K3G K4U K4F K6G K7G • MT 4158: D6G C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G • MT 4155: D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO D6U D6F D6S D6L D6D D6Y D6G D6M D6A D6Q D6T D6C D6B D6H D6V D6K D6R - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 218
• MT 4155: all models • MT 4158: all models • MT 4218: all models FRU, filler plate, Remy • MT 4155: all models • MT 4158: all models • MT 4218: all models FRUs FRU # 41N8294 41R5526 41R5630 41R2511 41R5547 41R5597 41R5636 CRU 2 CRU 2 1 2 2 2 2 1 210 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 219
FRU, memory chiller assembly • MT 4155: all models • MT 4158: all models • MT 4218: all models FRU, bezel kit • MT 4155: all models • MT 4158: all models • MT 4218: all models FRU, cable, signal, SLI bridge • MT 4155: all models • MT 4158: all models • MT 4218: all models Enhanced card and bracket - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 220
MT 4158: all models • MT 4218: all models FRU, miscellaneous parts kit • MT 4155: all models • MT 4158: all models • MT 4218: all models FRU, second serial port cable • MT 4155: all models • MT 4158 K3G K4U K5M • MT 4158: CTO D6U D6L D6G D6M K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 221
4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G N9G O1G O2G O3G O4G O5G O6G • MT 4218: Hong Kong/Taiwan • MT 4155: CTO • MT 4158: D6C D6B D6V N1B N3B N1V N3V • MT 4218: Czech • MT 4155: CTO D1G D4G 93G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 222
• MT 4158: CTO G7F G8F H9F K4F • MT 4158: CTO D6F F9F G7F H1F K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G K3G K6G K7G • MT 4158: CTO C2G C3G C5G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 223
MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 224
K6G K7G • MT 4158: CTO C2G C3G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G K3G K6G K7G • MT 4158: CTO C2G C3G C5G MT 4155: A2T • MT 4158: CTO D6T N1T N3T • MT K6G K7G • MT 4158: CTO C2G C3G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 225
MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G H8G H9G J1G L5G L6G L7G L8G L9G M1G M2G N1G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 226
4218: French • MT 4155: • MT 4158: • MT 4218: French Canadian • MT 4155: • MT 4158: • MT 4218: French Canadian • MT 4155: • MT 4158: • MT 4218: German • MT 4155: • MT 4158: • MT 4218: Keyboard - Full Size PS/2 218 ThinkStation Hardware Maintenance Manual FRU # 41A5044 CRU 1 41A5045 1 41A5046 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 227
MT 4218: Iceland • MT 4155: • MT 4158: • MT 4218: Italy • MT 4155: • MT 4158: • MT 4218: Japanese • MT 4155: • MT 4158: • MT 4218: Korean • MT 4155: • MT 4158: • MT 4218: LA Spanish • MT 4155: • MT 4158: • MT 4218: Norwegian • MT 4155: • MT 4158: • MT 4218: Keyboard - Full Size PS/2 FRU # 41A5054 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 228
4155: • MT 4158: • MT 4218: Spanish • MT 4155: • MT 4158: • MT 4218: Swedish/Finnish • MT 4155: • MT 4158: • MT 4218: Swiss French/German • MT 4155: • MT 4158: • MT 4218: Thailand • MT 4155: • MT 4158: • MT 4218: Keyboard - Full Size PS/2 220 ThinkStation Hardware Maintenance Manual FRU # 41A5063 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 229
: • MT 4218: UK English • MT 4155: • MT 4158: • MT 4218: US European • MT 4155: • MT 4158: • MT 4218: Slovenian • MT 4155: • MT 4158: • MT 4218: US English • MT 4155: • MT 4158: • MT 4218: Arabic • MT 4155: • MT 4158: • MT 4218: Arabic/French • MT 4155: • MT 4158: • MT 4218: Belgian/French • MT 4155 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 230
4155: • MT 4158: • MT 4218: Dutch • MT 4155: • MT 4158: • MT 4218: French • MT 4155: • MT 4158: • MT 4218: French Canadian • MT 4155: • MT 4158: • MT 4218: French Canadian • MT 4155: • MT 4158: • MT 4218: Keyboard - Enhanced Performance 222 ThinkStation Hardware Maintenance Manual FRU # 41A4965 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 231
: Greek • MT 4155: • MT 4158: • MT 4218: Greek/US • MT 4155: • MT 4158: • MT 4218: Hebrew • MT 4155: • MT 4158: • MT 4218: Hungarian • MT 4155: • MT 4158: • MT 4218: Iceland • MT 4155: • MT 4158: • MT 4218: Italy • MT 4155: • MT 4158: • MT 4218: Japanese • MT 4155: • MT 4158: • MT 4218: Korean • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 232
4155: • MT 4158: • MT 4218: Slovak • MT 4155: • MT 4158: • MT 4218: Spanish • MT 4155: • MT 4158: • MT 4218: Swedish/Finnish • MT 4155: • MT 4158: • MT 4218: French/German • MT 4155: • MT 4158: • MT 4218: Keyboard - Enhanced Performance 224 ThinkStation Hardware Maintenance Manual FRU # 41A4984 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 233
Performance Keyboard - USB Preferred Pro Fingerprint US English • MT 4155: CTO • MT 4158: CTO • MT 4218: Arabic • MT 4155: CTO • MT 4158: CTO • MT 4218: Arabic/French • MT 4155: CTO • MT 4158: CTO • MT 4218: FRU # 41A4994 CRU 1 41A4995 1 41A4996 1 41A4997 1 41A4998 1 41A4999 1 FRU - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 234
4155: CTO • MT 4158: CTO • MT 4218: Danish • MT 4155: CTO • MT 4158: CTO • MT 4218: Dutch • MT 4155: CTO • MT 4158: CTO • MT 4218: French • MT 4155: CTO • MT 4158: CTO • MT 4218: French Canadian • MT 4155: CTO • MT 4158: CTO • MT 4218: 226 ThinkStation Hardware Maintenance Manual FRU # 41R0041 CRU - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 235
Pro Fingerprint French Canadian • MT 4155: CTO • MT 4158: CTO • MT 4218: German • MT 4155: CTO • MT 4158: CTO • MT 4218: Greek • MT 4155: CTO • MT 4158: CTO • MT 4218: Greek/US • MT 4155: CTO • MT 4158: CTO • MT 4218: Hebrew • MT 4155: CTO • MT 4158: CTO • MT 4218: Hungarian • MT 4155: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 236
MT 4218: Serbian/Cyrillic • MT 4155: CTO • MT 4158: CTO • MT 4218: Slovak • MT 4155: CTO • MT 4158: CTO • MT 4218: Spanish • MT 4155: CTO • MT 4158: CTO • MT 4218: 228 ThinkStation Hardware Maintenance Manual FRU # 41R0061 CRU 1 41R0062 1 41R0063 1 41R0064 1 41R0065 1 41R0066 1 41R0067 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 237
G8U G8F G9M H1M H2M H9U H9F J1J J2J J3J J4J J5J J6J J7J J8J J9H K1G K2G K3G K4U K4F K5M K6G K7G • MT 4158: CTO D6U D6F D6S D6L D6D D6Y D6G D6M D6A D6Q D6T D6C D6B D6H D6V D6K D6R D6E F3M F4M F6M C2G C3G C5G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 238
detect) • MT 4155: CTO • MT 4158: CTO • MT 4218: L1 IEEE 1394 PCI adapter • MT 4155: CTO • MT 4158: CTO • MT 4218: Speakers (2-piece) Lenovo Logo (Secondary) • MT 4155: CTO • MT 4158: CTO • MT 4218: FRU # 45R8139 41D2781 41A5334 CRU 1 1 1 CRU 1 1 1 230 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 239
• MT 4218: 1.5GB NVIDIA FX4800 (DVI + DP + DP + ST), 2x3 power connector . • MT 4155: CTO • MT 4158: CTO • MT 4218: Dual FX4800 SLI enabled • MT 4155: CTO • MT 4158: CTO • MT 4218: SLI cable • MT 4155: CTO • MT 4158: CTO • MT 4218: FRU # 45C8640 CRU 1 45C8641 1 89P8571 1 42Y6329 1 71Y6863 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 240
cable (DMS59 to dual DVI) • MT 4155: CTO • MT 4158: CTO • MT 4218: Nvidia Tesla C1060 compute card (computer adapter) • MT 4155: CTO • MT 4158: CTO • MT 4218: 232 ThinkStation Hardware Maintenance Manual FRU # 46R2782 CRU 1 89Y0429 1 46R2794 1 46R2794 1 53Y8569 1 53Y8571 1 53Y8573 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 241
Adapters and miscellaneous FRUs SoundBlaster Titanium audio card (PCIe) • MT 4155: CTO • MT 4158: CTO • MT 4218: Modem phone cable • MT 4155: CTO • MT 4158: CTO • MT 4218: DVI to VGA dongle • MT 4155: CTO • MT 4158: CTO • MT 4218: 512MB NVIDIA Quadro NVS 450 GDDR3 (DP+DP+DP+DP) • MT 4155: CTO • MT - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 242
GDDR5 • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Power Cords Power Cords Line Cord - China • MT 4155: CTO D7C F9C • MT 4158: CTO D6C C6C N1C N3C • MT J6J J7J J8J • MT 4158: CTO D6E M5J M6J M7J M8J M9J N1E N1J N3E N3J • MT 4218: 234 ThinkStation Hardware Maintenance Manual FRU # 43N9160 CRU 1 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 243
Power Cords Line Cord - Brazil (Portuguese) • MT 4155: CTO • MT 4158: CTO N1P N3P • MT 4218: Line Cord - LA High Volt (APU) • MT 4155: CTO • MT 4158: CTO D6Y N1Y N3Y N1L N3L • MT 4218: Line Cord - Australia / New Zealand • MT 4155: CTO E7M G2M G9M H1M H2M K5M K6G K7G • MT 4158 CTO • MT 4158: CTO N1K - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 244
J7J J8J • MT 4158: CTO D6E M5J M6J M7J M8J M9J N1E N1J N3E N3J • MT 4218: Taiwan (for use on 2P systems only) • MT 4155: CTO • MT 4158: CTO D6B D6H D6V N1V N3V • MT 4218: FRU # 41R3228 41R3236 41R3220 41R3341 45J9502 43N9057 45J9503 CRU 1 1 1 1 1 1 1 236 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 245
Power Cords - Secondary Line Cord - China • MT 4155: CTO D7C F9C • MT 4158: CTO D6C C6C N1C N3C • MT 4218: Line Cord - Japan and Japanese English • MT 4155: CTO J1J J2J J3J J4J J5J J6J J7J J8J • MT 4158 4218: Line Cord - Korea • MT 4155: CTO • MT 4158: CTO N1K N1R N3K N3R • MT 4218: Line Cord - Hong - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 246
, if a model came with Windows XP Professional preinstalled from the factory, but has either a Windows 7 or Windows Vista COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system specified on the COA. 238 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 247
Russian English • MT 4155: CTO • MT 4158: CTO • MT 4218: French • MT 4155: CTO • MT 4158: CTO • MT 4218: German • MT 4155: CTO • MT 4158: CTO • MT 4218: Spanish • MT 4155: CTO • MT 4158: CTO • MT 4218: Brazilian • MT 4155: CTO • MT 4158: CTO • MT 4218: Windows Vista Business 32 FRU # 64Y5661 CRU - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 248
CTO • MT 4218: Finnish • MT 4155: CTO • MT 4158: CTO • MT 4218: Polish • MT 4155: CTO • MT 4158: CTO • MT 4218: Russian • MT 4155: CTO • MT 4158: CTO • MT 4218: Windows Vista Business 32 240 ThinkStation Hardware Maintenance Manual FRU # 64Y3677 CRU 1 64Y5662 1 64Y3699 1 64Y3700 1 64Y3697 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 249
Windows Vista Business 32 Turkish • MT 4155: CTO • MT 4158: CTO • MT 4218: Hungarian • MT 4155: CTO • MT 4158: CTO • MT 4218: Greek • MT 4155: CTO • MT 4158: CTO • MT 4218: Simplified Chinese • MT 4155: CTO • MT 4158: CTO • MT 4218: Traditional Chinese • MT 4155: CTO • MT 4158: CTO • MT 4218: - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 250
, if a model came with Windows Vista Business or Windows Vista Ultimate preinstalled from the factory, but has a Windows 7 COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system specified on the COA. 242 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 251
: CTO • MT 4218: Italian • MT 4155: CTO • MT 4158: CTO • MT 4218: Japanese • MT 4155: CTO • MT 4158: CTO • MT 4218: Norwegian • MT 4155: CTO • MT 4158: CTO • MT 4218: Swedish • MT 4155: CTO • MT 4158: CTO • MT 4218: Windows Vista Business 64 FRU # CRU 64Y5664 1 64Y3771 1 64Y3772 1 64Y3773 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 252
• MT 4218: Hungarian • MT 4155: CTO • MT 4158: CTO • MT 4218: Greek • MT 4155: CTO • MT 4158: CTO • MT 4218: Simplified Chinese • MT 4155: CTO • MT 4158: CTO • MT 4218: Windows Vista Business 64 244 ThinkStation Hardware Maintenance Manual FRU # CRU 64Y3794 1 64Y3790 1 64Y3777 1 64Y3795 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 253
Windows Vista Business 64 Traditional Chinese • MT 4155: CTO • MT 4158: CTO • MT 4218: Traditional Chinese - Hong Kong • MT 4155: CTO • MT 4158: CTO • MT 4218: Korean • MT 4155: CTO • MT 4158: CTO • MT 4218: Slovenian • MT 4155: CTO • MT 4158: CTO • MT 4218: Portuguese • MT 4155: CTO • MT 4158: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 254
4158: CTO • MT 4218: C&L Bel Lux (EN FR GR NL) • MT 4155: CTO • MT 4158: CTO • MT 4218: FRU # 64Y3799 64Y3800 Windows 7 Professional 64 SP1 Recovery CD Windows K6G K7G • MT 4158: CTO D6F G7F K3G K6G K7G • MT 4158: CTO C2G C3G C5G K6G K7G • MT 4158: CTO C2G C3G C5G K6G K7G • MT 4158: CTO C2G C3G C5G - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 255
Windows 7 Professional 64 SP1 Turkish • MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158: CTO C2G C3G C5G C7G C8G D2G O1G O2G O3G O4G O5G • MT 4218: Simplified Chinese • MT 4155: CTO D7C F9C • MT 4158: CTO B9C D6C D7C D8C D9C E1C E2C E3C E4C E5C C6C 96C 97C B7C B8C H2C H3C - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 256
Windows 7 Professional 64 SP1 India English • MT 4155: CTO • MT 4158: CTO D6Q N1Q N3Q • MT 4218: Hong Kong • MT 4155: CTO A4V • MT 4158: CTO D6B N1B N3B • MT 4218: Italian • MT 4155: CTO D1G D4G 93G 88G 89G G3G G4G G5G K1G K2G K3G K6G K7G • MT 4158 4158: 4158: MT 4158: CTO MT 4158: CTO MT 4158: CTO - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 257
J1J J2J J3J J4J J5J J6J J7J J8J • MT 4158: CTO M5J M6J M7J M8J M9J N1J N3J • MT 4218: FRU # 03W2899 03W2885 03W2894 03W2901 03W2906 03W2896 Windows 7 Ultimate 64 SP1 Recovery CD US English • MT 4155: CTO • MT 4158: CTO • MT 4218: CTO Windows 7 Ultimate 64 SP1 FRU # 03W2883 CRU 1 1 1 1 1 1 CRU - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 258
250 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 259
(VPD) code stored in the nonvolatile memory on the system board. After you replace the system board, the VPD must be updated. To update the VPD, see "Flash update procedures" on page 251. BIOS levels An incorrect level of BIOS can cause false errors and unnecessary FRU replacement. Use the following - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 260
a disc This section provides instructions on how to update (flash) BIOS from a disc. System program updates are available at: http://www.lenovo.com/support on the World Wide Web. 1. Make sure the optical drive you want to use is set as the first boot device in the startup device sequence. 2. Make - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 261
. 10. Insert the POST/BIOS update (flash) diskette into drive A, and turn on the computer and the monitor. 11. The recovery session will take two to three minutes. During this time you will hear a series of beeps. After the update session is completed, there will be no video, the series of beeps - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 262
254 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 263
to state or imply that only that Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead. However, it is the user's responsibility to evaluate and verify the operation - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 264
of Intel Corporation in the United States, other countries, or both. Microsoft, Windows, and Windows Vista are trademarks of the Microsoft group of companies. Other company, product, or service names may be trademarks or service marks of others. 256 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 265
ThinkStation computer feature an integrated memory controller, which provides the microprocessor with direct access to the system memory. Because of this design, the system memory supported system memory speed for your own computer model. Table 1. System memory Xeon X5650 Intel Lenovo 2008, 2012 257 - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 266
Table 1. System memory speed (continued) Intel Xeon W3550 Intel Xeon W3565 Intel Xeon W3570 Intel Xeon W3580 Intel Xeon W3680 Intel Xeon W5580 Intel Xeon 1066 MHz 1333 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 1066 MHz 258 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 267
© Copyright Lenovo 2008, 2012 L Lenovo Solution Center 35 M memory module, replacing 85 memory speed 257 O optical drive, replacing 101, 131 P password administrator 42 considerations 41 setting, changing, deleting 42 user 42 passwords, using 41 physical specifications 29 power supply, replacing - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 268
connectors 81, 113 T temporary startup device 43 U user, password 42 using passwords 41 Setup Utility 41 V viewing and changing settings 41 260 ThinkStation Hardware Maintenance Manual - Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 269
- Lenovo ThinkStation D20 | Hardware Maintenance Manual - Page 270
Part Number: 53Y4348 Printed in USA (1P) P/N: 53Y4348 *53Y4348*
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
-
109
-
110
-
111
-
112
-
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
-
123
-
124
-
125
-
126
-
127
-
128
-
129
-
130
-
131
-
132
-
133
-
134
-
135
-
136
-
137
-
138
-
139
-
140
-
141
-
142
-
143
-
144
-
145
-
146
-
147
-
148
-
149
-
150
-
151
-
152
-
153
-
154
-
155
-
156
-
157
-
158
-
159
-
160
-
161
-
162
-
163
-
164
-
165
-
166
-
167
-
168
-
169
-
170
-
171
-
172
-
173
-
174
-
175
-
176
-
177
-
178
-
179
-
180
-
181
-
182
-
183
-
184
-
185
-
186
-
187
-
188
-
189
-
190
-
191
-
192
-
193
-
194
-
195
-
196
-
197
-
198
-
199
-
200
-
201
-
202
-
203
-
204
-
205
-
206
-
207
-
208
-
209
-
210
-
211
-
212
-
213
-
214
-
215
-
216
-
217
-
218
-
219
-
220
-
221
-
222
-
223
-
224
-
225
-
226
-
227
-
228
-
229
-
230
-
231
-
232
-
233
-
234
-
235
-
236
-
237
-
238
-
239
-
240
-
241
-
242
-
243
-
244
-
245
-
246
-
247
-
248
-
249
-
250
-
251
-
252
-
253
-
254
-
255
-
256
-
257
-
258
-
259
-
260
-
261
-
262
-
263
-
264
-
265
-
266
-
267
-
268
-
269
-
270
 |
 |
ThinkStation
Hardware Maintenance Manual
Machine Type: 4105, 4155, 4157, 4158, 4217, 4218